Interstate 40 in Tennessee


Interstate 40 traverses the entirety of the state of Tennessee from west to east, running from the Mississippi River at the Arkansas border to the northern base of the Great Smoky Mountains at the North Carolina border. The road connects Tennessee's three largest cities—Memphis, Nashville, and Knoxville—and crosses all of Tennessee's physiographical provinces and Grand Divisions—the Mississippi Embayment and Gulf Coastal Plain in West Tennessee, the Highland Rim and Nashville Basin in Middle Tennessee, and the Cumberland Plateau, Appalachian Valley and Ridge Province, and Blue Ridge Province in East Tennessee. The Tennessee section of I-40 is long, the longest of any state on the route.

Route description

West Tennessee

Memphis

I-40 enters Tennessee via the six lane Hernando de Soto Bridge, which spans the Mississippi River at river mile 736. Immediately within the city of Memphis, the interstate passes across the southern half of Mud Island before crossing the Wolf River Harbor into downtown Memphis. Throughout Memphis, the highway contains a minimum of six through lanes, except through major interchanges. Upon reaching Memphis, I-40 immediately has an interchange with U.S. Route 51, and from the state line is an interchange with the western terminus of I-240, where I-40 abruptly turns north, following a route formerly designated as part of I-240. About one mile later, I-40 has an interchange with State Route 14, and about beyond this point, the highway crosses the Wolf River again and has an interchange with the eastern terminus of SR 300, a controlled-access connector to US 51. At this interchange, the Interstate turns sharp east. Passing first near the neighborhoods of Frayser and Raleigh, about later, I-40 crosses the Wolf River for a third time as the highway turns southeast, and has an interchange with SR 14 again. Two miles later is an interchange with SR 204, and beyond this point, I-40 comes to a complicated interchange with US 64/US 70/US 79, I-240 southbound and Sam Cooper Boulevard eastbound, and turns sharp northeast, leaving Memphis. For the next several miles the highway is known as the Isaac Hayes Memorial Highway and is eight lanes, the left lanes functioning as HOV lanes during rush hour, passing through several major suburbs of Memphis, including Bartlett, Cordova, and Lakeland. At exit 18, which is US 64, the highway narrows to six lanes, and to four lanes a short distance beyond. Several miles later, near Arlington, at exit 24, is a cloverleaf interchange with I-269/SR 385.

Gulf coastal plain

About one mile east of Arlington, I-40 enters Fayette County, and about another mile later crosses the Loosahatchie River and leaves the Memphis area, traversing through the Gulf Coastal Plain in a very flat and straight stretch of mostly farmland with some rural woodlands, bypassing most cities and communities. At exit 35 is an interchange with SR 59, which connects to Covington and Somerville. About later, I-40 enters Haywood County, and about later, the highway turns north and enters the Hatchie National Wildlife Refuge and crosses the Hatchie River. Upon exiting the refuge about later, I-40 turns east and passes just southeast of Brownsville, where it has an interchange first with SR 76, which also connects to Somerville. Eight miles later is an interchange with US 70, and later, I-40 enters Madison County. Entering Jackson, at mile marker 78, the interstate crosses the South Fork of the Forked Deer River. Passing through the northern half of the city, I-40 has a total of six exits in Jackson. First, at mile 79, is an interchange with US 412, then about later an interchange with the US 45 Bypass. About later is an interchange with US 45, which also connects to Humboldt and Milan, and about later is an interchange with US 70, which also connects to Huntingdon, and I-40 leaves Jackson at this point. From this point, I-40 continues east northeast through a sparsely populated area of farmland and woodlands, and about later enters Henderson County. About later, near the community of Parkers Crossroads, I-40 has an interchange with SR 22, a major north-south connector route in west Tennessee, which, at this interchange, is signed as a connector to Lexington and Huntington. A few miles later, I-40 crosses the Big Sandy River before proceeding through the northern half of the Natchez Trace State Park, and around milepost 120 enters Decatur County. About later is an interchange with US 641/SR 69, another major north-south corridor, which at this point connects to Camden and Decaturville. I-40 then enters Benton County, and about later, descends about on a steep grade over the course of a mile, the westbound lanes gaining a truck climbing lane, before crossing the Tennessee River into Middle Tennessee on the Jimmy Mann Evans Memorial Bridge. This river crossing is also located within the Tennessee National Wildlife Refuge.

Middle Tennessee

Western highland rim

Upon crossing the Tennessee River into Humphreys County, I-40 traverses through mostly vast woodlands in the rugged hills of the Western Highland Rim for a considerable distance. This section is characterized by several noticeable upgrades and downgrades, with mostly minor curves. About beyond the Tennessee River is an interchange with SR 13, which connects to Linden and Waverly. About later, I-40 crosses into Hickman County and has an interchange with SR 50, which connects to Centerville. I-40 then crosses the Duck River, traveling through mostly wooded areas characterized by further rugged terrain, and at mile 163 is an interchange with SR 48, the first exit for Dickson. I-40 then enters Dickson County, and shortly beyond this point crosses the Piney River. About is an interchange with SR 46, the second Dickson exit which also connects to Centerville and Columbia. Approaching the urban parts of the Nashville metropolitan area, later is the western terminus of Interstate 840, the outer southern beltway around Nashville. The highway continues through mostly woodlands and rugged terrain, and crossing into Williamson County, I-40 briefly enters a steep ascent, gaining a truck climbing lane on the eastbound side, and beyond I-840 has an interchange with SR 96, which connects to the Nashville suburbs of Fairview and Franklin. A few miles later, I-40 enters Cheatham County, and descends into the Nashville Basin between mile markers 186 and 188, and still in a predominantly rural area, has an interchange with SR 248 in Kingston Springs. I-40 the crosses the Harpeth River twice over a distance of about.

Nashville

Around milepost 191, I-40 enters Davidson County, and a few miles later crosses the Harpeth River for a third time. About a mile later, near
Bellevue, I-40 widens to six lanes, entering the urban outskirts of Nashville, and has an interchange with US 70S. Three miles later is an exit with SR 251, and later is an interchange with US 70. Widening to eight lanes, three miles later is an interchange with SR 155, including the western terminus of the northern controlled-access beltway around Nashville. About two miles later is the western terminus of I-440, the southern loop around central Nashville. Two miles later, I-40 enters Downtown Nashville, and begins a brief concurrency with I-65, turning southeast. As part of the route around downtown Nashville known locally as the Downtown Loop, the two concurrent routs have interchanges with US 70 and US 70S/431, as well as two surface streets, Church Street and Demonbreun Street. About two miles later the two concurrent routes turn east northeast, and I-65 splits off and heads south. Briefly on its own for about, I-40 crosses a long viaduct, and has an interchange with US 31A/41A, before beginning a brief concurrency with I-24 and turning southeast. About later, I-24 splits off, and I-40 turns east. The eastern terminus of I-440 is also directly accessible from the east bound lanes of I-40 at this interchange, and US 41, which crosses I-24 before this interchange, is also directly accessible from I-40 at this interchange.
About later, I-40 has an interchange with SR 155 near the Nashville International Airport, and about a mile later, the eastbound lanes have a direct access partial-y exit to a surface road to the airport. The westbound lanes of I-40 are only accessible from this interchange. Less than a half mile later is an exit with SR 255, and beginning here, the left lanes of I-40 function as HOV lanes during rush hour. Passing near J. Percy Priest Dam, I-40 has an interchange with Stewarts Ferry Pike, then crosses the Stones River, and has an interchange with SR 45. Also at this interchange is a separate partial y interchange which provides access to SR 45 via a bypass which junctions with SR 45 about north of I-40. This bypass is only accessible via the eastbound lanes of I-40, and the westbound lanes are only accessible from it. About later, I-40 enters Wilson County, and few miles later has an interchange with SR 171 near the Nashville suburb of Mount Juliet. Six miles later is an interchange with SR 109, which connects to Gallatin. About later and about east of Nashville, the route narrows back to four lanes and has an interchange with the eastern terminus of I-840 a few miles east of Lebanon. I-40 the enters Lebanon and has interchanges with US 231 and US 70.

Eastern Highland Rim and Cumberland Plateau

For the next roughly, I-40 continues across mostly open farmland, passing near mostly small communities. About east of Lebanon, I-40 enters Smith County, and less than later I-40 begins a steep ascent where the eastbound lanes gain a truck climbing lane. This lane terminates about later, and about beyond this point is an interchange with SR 53 near Carthage and Gordonsville. Between mileposts 263 and 266, I-40 crosses the meandering Caney Fork River five times before crossing into Putnam County and beginning its ascent out of the Eastern Highland Rim onto the Cumberland Plateau. At milepost 268, I-40 has an interchange once again with SR 96, and a few miles later reaches an elevation of for the first time in the state near Silver Point, and beginning at the edge of the table-top rim at mile marker 272 near Baxter, the interstate remains relatively flat across the plateau. I-40 then immediately has an interchange with SR 56 southbound/SR 141, which connect to Smithville and McMinnville. Beginning a concurrency with SR 56 at this point, the latter route splits off later, heading north towards Gainesboro. Reaching Cookeville about later, I-40 has a total of five interchanges,
including with SR 111, a major north-south connector to Chattanooga, and US 70N. Beginning a few miles beyond this point, I-40 begins another steep uphill ascent, protracted over a distance of about, reaching an elevation of nearly. Through this section, the speed limit reduces to 65 mph, and 55 mph for trucks on the westbound descent. Continuing through a predominantly wooded area, continues for about through a predominantly wooded area, before reaching Monterey a few miles later, where the route has two interchanges with US 70N, which contain concurrencies with SR 84 and SR 62, respectively. A short distance later, I-40 reaches an elevation of over for the first time in Tennessee, before crossing into Cumberland County and East Tennessee about.

East Tennessee

Cumberland Plateau and Tennessee Valley

After ascending further up into the Walden Ridge/Cumberland Plateau and passing through Monterey, I-40 remains relatively flat and straight as it continues across the Cumberland Plateau. At mile 308, I-40 crosses the Tennessee Divide, where the Cumberland and Tennessee River watersheds meet. The divide is marked in the eastbound lanes with a sign reading "Entering Emory River watershed." In the westbound counterparts is a sign noting the beginning of the Caney Fork watershed. About ten miles later, I-40 reaches Crossville, and has three interchanges, including one with US 127, which also conbects to Jamestown.
East of Crossville, the Crab Orchard Mountains, the southern fringe of the Cumberland Mountains, come into view as the road descends several hundred feet. At mile 329, the interstate enters Crab Orchard Gap and proceeds through a narrow valley once prone to rockslides. About later, I-40 has an interchange with US 70 near the town of Crab Orchard. Beyond this point, the Interstate descends into a short depression before crossing into Roane County and mile 340, entering the Eastern Time Zone. Shortly thereafter the road begins its descent of the Cumberland Plateau into the Tennessee Valley and the speed limit drops to 60 mph in the eastbound lanes. I-40 hugs the slopes of the plateau's Walden Ridge escarpment for several miles, containing what some describe as dramatic views of the Tennessee Valley below to the south, before reaching the base of the plateau at mile 347 between Harriman and Rockwood, and containing an interchange with US 27. As it enters the Ridge-and-Valley province of the Appalachians, of which the Tennessee Valley is a part, I-40 crosses a series of ridges and valleys characteristic of the region's topography. About later is an interchange with SR 29, and about later, the road crosses the Clinch River, with the Kingston Fossil Plant and its twin smokestacks dominating the view to the north. About later is an interchange with SR 58 southbound in Kingston, and at this point, I-40 begins a brief concurrency with SR 58. After ascending a short and relatively steep ridge out of the Clinch River Valley, SR 58 splits off to the north about later, heading towards Oak Ridge. Continuing through the relatively rugged terrain of the Great Appalachian Valley and crossing additional ridges, I-40 crosses into Loudon County about later and has an interchange with US 321/SR 95 near Lenoir city, before reaching I-75 about later.

Knoxville

At exit 368, about 20 miles west southwest of downtown Knoxville, I-40 merges with I-75, which continues to the southwest to Chattanooga, and the two routes turn east northeast, carrying six through lanes, and cross into Knox County a short distance later. Throughout this concurrency, exits are numbered according to I-40 mileage. The two highways pass through several of the western suburbs of Knoxville, including Farragut, and have interchanges with a few surface streets. At exit 374, the highway widens to eight lanes and at the next exit, about later, is an interchange with the Pellissippi Parkway, which connects to Oak Ridge and Maryville, respectively. Continuing through western Knoxville, the two routes have interchanges with additional surface streets, before reaching an interchange with US 11/70 later near the West Hills neighborhood. Two miles later is an interchange with SR 332, and the separate Papermill Drive and Weisgarber Road. This segment of I-40 and I-75 is the most heavily traveled section of highway in Tennessee, with an annual average daily traffic volume of more than 210,000 vehicles. Two miles later, at exit 385, is an interchange with the western terminus of I-640, a beltway which passes northwest of downtown Knoxville. Also at this exit, I-75 splits off from I-40 onto a concurrency with I-640, splitting off a few miles later and heading towards Lexington, Kentucky. The route then enters downtown Knoxville, containing a minimum of six through lanes through the entirety of central Knoxville, as well as several short segments of auxiliary lanes between exits. Passing near the main campus of the University of Tennessee, as well as several residential neighborhoods, about past I-640 is an interchange with US 129, which connects to McGhee Tyson Airport and is a route to the Great Smoky Mountains National Park. One mile later is an interchange with SR 62, and a mile beyond this point is an interchange with I-275. About later, in a complicated interchange, I-40 has an interchange with US 441 south, and begins a brief concurrency with this route, which splits off about later, along with SR 158 westbound, as controlled-access James White Parkway. I-40 then curves sharp north, and about later, sharp east again before coming to an interchange with a connector road to US 441. I-40 then crosses a long viaduct, and has an interchange with a surface street before reaching an interchange with US 11W. The highway then enters a predominantly residential area, passing next to the Knoxville Zoo, before coming to an interchange with the eastern terminus of I-640 and leaving Knoxville less than later. Also at this interchange, I-40 begins a brief concurrency with US 25W, which splits off a little over later at an interchange with US 11E/70. Leaving Knoxville, I-40 crosses the Holston River about later.

Smoky Mountains and Pigeon River gorge

Continuing east as a six-lane highway, I-40 travels through a semi-rural residential area before crossing into Sevier County. A few miles later, at exit 407, near Sevierville, I-40 has an interchange with the northern terminus of the Great Smoky Mountains Parkway. This interchange is the primary means of access to the Great Smoky Mountains National Park, as well as the tourist attractions in the cities of Sevierville, Pigeon Forge and Gatlinburg, and, as a result, is reportedly one of the busiest and most congested non-interstate exits in the state. A few miles later, I-40 crosses into Jefferson County, and about later is an interchange with US25W/70 in Dandridge. Two miles later is an interchange with SR 92, also in Dandridge. Four miles later, at exit 421 is the interchange with the southern terminus of I-81, which runs into Northeast Tennessee to the so called "Tri-Cities" of Bristol, Kingsport, and Johnson City. At this interchange, I-40 reduces back to four lanes and turns sharp southeast, crossing the Douglas Dam impoundment of the French Broad River about later, as well as into Cocke County. About later is an interchange with US 411/70S/25 near Newport. Traveling along the northern base of English Mountain for a few miles, I-40 has an interchange with US 321 three miles later. About later the road has an interchange with SR 73 near Cosby, and turns south through the gap between English Mountain and Stone Mountain, revealing a dramatic view of the Mount Cammerer at the northeastern end of the Great Smokies range. Also at this point, I-40 enters the Cherokee National Forest and proceeds into the Pigeon River Gorge through the Blue Ridge Mountains, closely following the north bank of the river. This section is extremely curvy and the speed limit reduces to 55 mph due to its susceptibility to accidents. This stretch is also prone to rockslides, and contains mesh nets along some of the cliff slopes as preventative measures. A few miles later I-40 crosses the Pigeon River and has an interchange with the Foothills Parkway, before crossing the pigeon river again about later and curving sharply to the east. A bout later, the route curves to the south again near the unincorporated community of Hartford before entering North Carolina about later.

Music Highway

The term Music Highway refers to the section of I-40 between Memphis and Nashville. I-40 was designated as such by an act of the Tennessee Legislature in 1997 "from the eastern boundary of Davidson County to the Mississippi River in Shelby County," a distance of about. I-40 is designated as such because of the rich music history in Memphis, Nashville, and the areas in between. Memphis is known as "the Home of the Blues and the Birthplace of Rock and Roll." Nashville is known as "Music City USA" for its influence on numerous types of music, especially country. Several cities and towns between the two, such as Jackson, Brownsville, Nutbush, Waverly and others were birthplaces or homes of numerous singers and songwriters. Signs that display the words "Music Highway" along with music notes are erected in both directions along I-40, especially at the borders of Shelby and Davidson counties. In addition, the rest areas along this stretch are each named for musicians or bands associated with areas along this stretch of I-40.

History

Construction and early history

The Tennessee leg of I-40 was part of the original of Interstate Highways authorized for Tennessee by the Federal Aid Highway Act of 1956. The first completed segment of Interstate 40 in Tennessee was the approximately segment between Unaka Street and Gay Street in Knoxville, which was grandfathered into the interstate system. Known initially as the Magnolia Avenue Expressway and later renamed the Frank Regas Expressway, the first segment, between Unaka Street and Tulip Avenue, was completed in November 1952, and the second segment, located between Tulip Avenue and Gay Street, was completed on December 10, 1955. This was the first freeway constructed in Tennessee, and contained a cloverleaf interchange, named for the late Grace Moore, which was later used as the interchange with I-75 and US 441. The first initial segment of I-40 in Tennessee, located between Nonconnah Creek and Hindman Ferry Road in Memphis, was contracted on February 14, 1956, and on March 4, 1956, a design contract was awarded for the first section in Davidson County. Within a year contracts had been awarded for sections in Davidson, Knox, Roane, Haywood, Madison, Jefferson, and Cocke counties. By 1958, sections in Loudon, Smith, Putnam, Cumberland, Humphreys, Hickman, and Sevier counties had been contracted. In 1960 additional contracts were awarded for design and construction of segments in Wilson, Dickson, Williamson, Henderson, Benton, and Haywood counties.
The section between US 70 east of Brownsville and US 70 in Jackson, referred to at the time as the "Jackson Bypass," was dedicated and opened to traffic on December 1, 1961. On December 2, 1961 the approximately segment of I-40 between SR 58 in Kingston and near the present location of the western terminus of I-640 in Knoxville was opened to traffic. The first section of I-40 in Middle Tennessee to be completed was the stretch between SR 96 in Williamson County and US 70S in Bellevue, opened on November 4, 1962. The segment between US 70S and US 70 in west Nashville was opened on November 15, 1962. In late 1962, the section between SR 113 near Dandridge and US 411/US 25W/ US 70 in Newport was completed. The segment between SR 56 near Silver Point and US 70N in Cookeville was completed in December 1962. The segment between SR 59 near Braden and US 70 east of Brownsville was dedicated and opened to traffic on December 17, 1963. That same month the segment between SR 53 in Gordonsville and SR 56 near Silver Point was completed. On December 14, 1964, two separate sections; the section between I-240 in East Memphis and SR 59 in Braden and the section between US 70 in Jackson and SR 22 in Henderson County were dedicated and opened.
Work began on the approximately bridge over the Tennessee River on November 29, 1962, and was completed on July 21, 1965. On August 26, 1965, the stretch between SR 45 in eastern Nashville and US 70 in Lebanon was dedicated and opened to traffic. The segment between SR 13 in Humphreys County and SR 230 in Hickman County, including the bridge over the Duck River, was completed on November 24, 1965. In December 1965, three segments were completed. These were the stretch between US 70 in Lebanon and SR 53 in Gordonsville, the segment between the Tennessee River and SR 13 in Humphreys County, and the segment between US 411/US 25W/US 70 and US 321 in Cocke County. On July 24, 1966, I-40 was completed between Memphis and Nashville, with the dedication of the segment between SR 22 in Henderson County and SR 46 near Dickson. This was the first segment completed between two major cities in Tennessee.
In late 1966, the segment between US 25W/70 and SR 113 in Jefferson County was completed. The segment between US 70N in Monterey and US 127 in Crossville was opened to traffic on December 1, 1967. The long segment between US 127 in Crossville and US 70 in Crab Orchard was opened to traffic on September 12, 1968. On September 26, 1969, the section between US 70 in Crab Orchard and SR 299 near Westel Springs was opened to traffic. The section along the Pigeon River Gorge in Cocke County, as well as into North Carolina, was initially believed by many to be impossible to construct. Construction of this segment was one of the most difficult and laborious highway construction projects in the nation, requiring thousands of tons of earth and rock to be moved. It was also one of the most expensive highway construction projects per mile, at a cost of $19 million. Work began on this segment in 1961, and the segment between US 321/SR 32 in Newport and US 276 in Haywood County, North Carolina was jointly opened to traffic on October 24, 1968 by both states in a dedication ceremony.
The approximately segment between 46th Avenue in West Nashville and the interchange with I-65 in North Nashville opened to traffic on March 15, 1971. Work on the final segment between Memphis and Knoxville, the segment between the interchange with I-65 in North Nashville and the split with I-24 southeast of downtown Nashville, began in May 1969 and was opened to traffic on March 3, 1972, completing the entirety of I-40 between Memphis and SR 299 near Rockwood. The last segment of the original planned route of I-40 in West Tennessee to be completed was the Hernando de Soto Bridge in Memphis, which broke ground in May 1967, and was opened to traffic on August 2, 1973. The bridge was officially dedicated in a cermony by both states on August 17, 1973. The segment between SR 299 and US 27 near Harriman and Rockwood, including the descent up Walden Ridge, was opened to traffic on August 19, 1974 after years of delays due to geological difficulties, opening the entirety of the route between Memphis and Knoxville. Work started on this section in 1966. The final segment of the planned route of I-40 in Tennessee, the stretch located between US 11E/25W/70 east of Knoxville and US 25W/70 in Dandridge, was dedicated and opened to traffic on December 20, 1974 and completed on September 12, 1975. This segment was constructed with six lanes, making it one of the first rural six lane sections of interstate in the country, and was opened on the same day that the last section of I-75 and I-81 in Tennessee were opened.

Overton Park controversy

In Memphis, I-40 was originally slated to pass through the city's Overton Park, a public park. This location was announced in 1955 and subsequently approved by the Bureau of Public Roads, the predecessor to the Federal Highway Administration, the following year. The park consists of a wooded refuge, as well as the Memphis Zoo, the Memphis Brooks Museum of Art, the Memphis College of Art, a 9-hole golf course, an amphitheater that was the site of Elvis Presley's first paid concert in 1954, and other features. When the state announced plans to route I-40 through Overton Park, a group of local citizens, spearheaded by a group of elderly women dubbed the "little old ladies in Tennis shoes" by multiple media outlets, began a campaign to stop this construction. The organizers first collected over 10,000 signatures in their support, and founded the organization Citizens to Preserve Overton Park in 1957. The movement was also backed by environmentalists, who feared that the interstate's construction would upset the park's fragile ecological balance, as the wooded area had become an important stopover for migratory birds.
The organization waged a 12-year legal battle to prevent highway construction in the park, culminating in the 1971 United States Supreme Court decision, Citizens to Preserve Overton Park v. Volpe. The Supreme Court remanded the case to the District Court for further review, and it ruled that the highway commission had not adequately explored alternative routes. For many years after this case, the state continued to explore options to route I-40 through Overton Park, including tunneling under the park or constructing the highway below grade. On January 26, 1981, the highway commission abandoned plans to route I-40 through Overton Park, and instead redesignated the northern portion of I-240 as I-40.
Several miles of a controlled-access road were actually built within the I-240 loop east of the park; this portion of highway still exists and is in regular use as Sam Cooper Boulevard, reaching the eastern end of Chickasaw Country Club and the Binghampton neighborhood, and then East Parkway. For over 20 years, I-40 signage existed on this segment. In addition, right of way was acquired west of the park, and many structures demolished to make way for the interstate. Most of these empty lots have since been built over.

Later developments and improvements

Since its initial completion, much of I-40 in Tennessee has been reconstructed or widened.
In the late 1970s and early 1980s, multiple projects on I-40 in the Knoxville area were conducted in preparation for the 1982 World's Fair. Beginning in late 1978, the segment between SR 332 and Gay Street was modified in a project that eliminated the interchanges with 17th Street, Western Avenue, and Gay Street, widened the segment to a minimum of three through lanes in each direction, added frontage roads, and reconstructed the cloverleaf interchange with I-75 into a stack interchange with flyover ramps. This project was completed on March 31, 1982. At the same time, the concurrent part of I-75 on this segment was rerouted around I-640, and the short segment of I-75 north of this segment became I-275. The concurrent segment with I-75 between the interchange near Lenoir City and Papermill Road was also widened to six lanes at the same time.
The first HOV lanes on I-40 in Tennessee were opened to traffic on November 14, 1996 with the completion of a project that widened the section between Old Hickory Boulevard in East Nashville and SR 171 in Mt. Juliet from four and six to eight lanes. These were the second set of HOV lanes constructed in Tennessee. This project, which began in early 1995, was also the first in Tennessee to be constructed with split Jersey barriers in the median every few miles to allow police to enforce the HOV lanes from the median. A project which widened I-40 from four to eight lanes from I-240 in Memphis was completed in September 1997. This project added the first HOV lanes in Memphis.
Reconstruction of the interchange with the western terminus of I-240 and Sam Cooper Boulevard in eastern Memphis, which was necessitated by the fact that the interchange had been constructed in anticipation of I-40 continuing onto the present Sam Cooper Boulevard and the single lane ramps carrying I-40 traffic through the interchange were inadequate to handle the traffic load, was accomplished in two separate projects. The first project, which began in January 2001 and was completed in October 2003, constructed a new two-lane flyover ramp from I-40 westbound to I-240 westbound, replacing a single-lane loop ramp, and widened I-240 south of the interchange. Also in this project, I-40 directly north of the interchange was reconstructed in preparation for the second project and the interchanges with Summer Avenue and White Station Road were modified. The second project was initially slated to begin in January 2004, but was delayed until October 2013 due to funding and redesign. It included the construction of a two-lane flyover that carries I-40 eastbound traffic through the interchange. This flyover replaced a one-lane ramp with a slow design speed that had been the site of several accidents over the years. The single-lane ramp carrying I-40 westbound traffic through the interchange was replaced with a two-lane flyover that connected to the flyover constructed in the first project, and the former ramp was rerouted to become the exit ramp for the Summer Avenue exit. The ramp connecting I-240 eastbound to I-40 eastbound was also widened to three lanes. Additional aspects of this project included the widening of I-40 between the interchange and Covington Pike, which required the replacement of the Wolf River Bridge with a 14-lane bridge, widening of I-240, addition of through lanes on Sam Cooper Boulevard, and reconfiguration of the Covington Pike interchange. The project cost $109 million, which was at the time the highest bid project in TDOT history, and was completed on December 15, 2016.
The interchange with the eastern terminus of I-240 near downtown Memphis was reconstructed between 2003 and 2006. This project included converting the interchange into a T-interchange, and the demolition of several unused ramps and bridges that had been constructed with the intent of I-40 continuing directly east of this interchange prior to the Overton Park controversy.
Between May 1, 2008 and June 12, 2009, a section of I-40 through downtown Knoxville between James White Parkway and Hall of Fame Drive was completely closed to all traffic for reconstruction. Through traffic was required to use I-640 or surface streets. The four-lane section, which was quite substandard, congested, and accident-prone, was widened to six lanes to improve traffic flow and safety in a project known as "SmartFix 40." Several interchanges along that stretch were also reconstructed.
TDOT officially announced the I-40/I-81 Corridor Feasibility Study on July 27, 2007. The intent of this study is to assess deficiencies along I-40 and I-81 in Tennessee and to develop upgrade proposals for the existing corridor. This study was completed in 2008.
A project to widen I-40 to eight lanes from east of SR 171 to east of SR 109 in Lebanon began in July 2012. Initially expected to be completed in December 2013, the project was delayed by more than six months due to inclement weather. A project to widen I-40 between SR 109 and I-840 in Lebanon began in April 2019. This followed a project several miles east in Smith County, which widened the eastbound side to three lanes over a three-mile stretch and added more shoulder space. This was done to help relieve congestion caused by large trucks ascending a hill into the New Middleton community.
On January 18, 2008, the Federal Highway Administration authorized the states of Mississippi and Tennessee to extend I-69 from the I-40/SR 300 interchange in north Memphis to the I-55/I-69 interchange in Hernando, Mississippi; however, Tennessee has signed the extension of the route, although Mississippi has already done so.

Geological difficulties

The rugged terrain of East Tennessee presented numerous challenges for I-40 construction crews and engineers. Rockslides, especially along the eastern Cumberland Plateau and in the Pigeon River Gorge, have been a persistent problem since the road's construction.

Crab Orchard

In December 1986, a truck driver was killed when his truck skidded across some rocks that had spilled across the road just east of Crab Orchard between miles 331 and 333. In response, the Tennessee Department of Transportation flattened the cutslopes along this stretch of Interstate and moved the road away from the problematic cliffside.
Twenty rockslides occurred along the Walden Ridge section, miles 341–346, of the eastern plateau in 1968 alone, prompting various remedial measures throughout the 1970s, including the employment of rock buttresses, gabion walls, and horizontal drains. A minor rockslide shut down the right lane of westbound I-40 at mile 343 on May 6, 2013.

Pigeon River Gorge

An area very prone to rockslides is the Pigeon River Gorge, especially in the vicinity of the Tennessee–North Carolina state line. Throughout the 1970s, this stretch of I-40 was repeatedly shut down by rockslides, sometimes for several weeks at a time. In the late 1970s and early 1980s, TDOT dug over of horizontal drains, blasted out large volumes of unstable rocks, and installed massive mesh catchment fences. Nevertheless, rockslides in 1985 and 1997 again forced the closure of I-40 in the Pigeon River Gorge for several weeks. Additional stabilization measures were implemented, including the blasting of loose rock, the installation of rock bolts, and the construction of a better drainage system. In spite of these measures, another massive rock slide occurred in the Pigeon River Gorge on October 26, 2009, blocking all lanes just across the border at North Carolina mile 3. The section was closed to traffic in both directions until April 25, 2010. On January 31, 2012, the westbound lanes of I-40 were closed because of a rockslide near the North Carolina border. Traffic was detoured along I-26 and I-81 and reopened a few months later.

Sinkholes

Sinkholes are a consistent issue along highways in East Tennessee. One particularly problematic stretch is a section of I-40 between miles 365 and 367 in Loudon County, which is underlain by cavernous rock strata. In the 1970s and 1980s, TDOT employed numerous stabilization measures in this area, including backfilling existing sinkholes with limestone, collapsing potential sinkholes, and paving roadside ditches to prevent surface water from seeping into the volatile soil.

Exit list

Auxiliary routes