Space Shuttle Columbia disaster


The Space Shuttle Columbia disaster was a fatal incident in the United States space program that occurred on February 1, 2003, when the disintegrated as it reentered the atmosphere, killing all seven crew members. The disaster was the second fatal accident in the Space Shuttle program, after the 1986 breakup of soon after liftoff.
During the launch of STS-107, Columbias 28th mission, a piece of foam insulation broke off from the Space Shuttle external tank and struck the left wing of the orbiter. Similar foam shedding had occurred during previous shuttle launches, causing damage that ranged from minor to nearly catastrophic, but some engineers suspected that the damage to Columbia was more serious. Before reentry, NASA managers had limited the investigation, reasoning that the crew could not have fixed the problem if it had been confirmed. When Columbia reentered the atmosphere of Earth, the damage allowed hot atmospheric gases to penetrate the heat shield and destroy the internal wing structure, which caused the spacecraft to become unstable and break apart.
After the disaster, Space Shuttle flight operations were suspended for more than two years, as they had been after the Challenger disaster. Construction of the International Space Station was put on hold; the station relied entirely on the Russian Roscosmos State Space Corporation for resupply for 29 months until Shuttle flights resumed with STS-114 and 41 months for crew rotation until STS-121.
NASA ultimately made several technical and organizational changes, including adding a thorough on-orbit inspection to determine how well the shuttle's thermal protection system had endured the ascent, and keeping a designated rescue mission ready in case irreparable damage was found. Except for one final mission to repair the Hubble Space Telescope, subsequent shuttle missions were flown only to the ISS so that the crew could use it as a haven if damage to the orbiter prevented safe reentry.

Crew

The shuttle's main fuel tank was covered in thermal insulation foam intended to prevent ice from forming when the tank is full of liquid hydrogen and oxygen. Such ice could damage the shuttle if shed during lift-off.
Mission STS-107 was the 113th Space Shuttle launch. Planned to begin on January 11, 2001, the mission was delayed 18 times and eventually launched on January 16, 2003, following STS-113. The Columbia Accident Investigation Board determined these delays had nothing to do with the catastrophic failure.
At 81.7 seconds after launch from Kennedy Space Center's LC-39-A, a suitcase-sized piece of foam broke off from the external tank, striking Columbias left wing reinforced carbon-carbon panels. As demonstrated by ground experiments conducted by the Columbia Accident Investigation Board, it is likely that this created a hole, allowing hot gases to enter the wing when Columbia later reentered the atmosphere. At the time of the foam strike, the orbiter was at an altitude of about, traveling at Mach 2.46.
The left bipod foam ramp is an approximately aerodynamic component made entirely of foam. The foam, not normally considered to be a structural material, is required to bear some aerodynamic loads. Because of these special requirements, the casting-in-place and curing of the ramps may be performed only by a senior technician. The bipod ramp was originally designed to reduce aerodynamic stresses around the bipod attachment points at the external tank, but it was proven unnecessary in the wake of the accident and was removed from the external tank design for tanks flown after STS-107.
Bipod ramp insulation had been observed falling off, in whole or in part, on four previous flights: STS-7, STS-32, STS-50, and most recently STS-112. All affected shuttle missions completed successfully. NASA management referred to this phenomenon as "foam shedding". As with the O-ring erosion problems that ultimately doomed the, NASA management became accustomed to these phenomena when no serious consequences resulted from these earlier episodes. This phenomenon was termed "normalization of deviance" by sociologist Diane Vaughan in her book on the Challenger launch decision process.
As it happened, STS-112 had been the first flight with the "ET cam", a video feed mounted on the ET for the purpose of giving greater insight to the foam shedding problem. During that launch a chunk of foam broke away from the ET bipod ramp and hit the SRB-ET attachment ring near the bottom of the left solid rocket booster causing a dent wide and inches deep in it. After STS-112, NASA leaders analyzed the situation and decided to press ahead under the justification that "he ET is safe to fly with no new concerns " of further foam strikes.
Video taken during lift-off of STS-107 was routinely reviewed two hours later and revealed nothing unusual. The following day, higher-resolution film that had been processed overnight revealed the foam debris striking the left wing, potentially damaging the thermal protection on the Space Shuttle. At the time, the exact location where the foam struck the wing could not be determined due to the low resolution of the tracking camera footage.
Meanwhile, NASA's judgment about the risks was revisited. Linda Ham, chair of the Mission Management Team, said, "Rationale was lousy then and still is." Ham and Shuttle Program manager Ron Dittemore had both been present at the October 31, 2002 meeting where the decision to continue with launches was made.
Post-disaster analysis revealed that two previous shuttle launches also had bipod ramp foam loss that went undetected. In addition, protuberance air load ramp foam had also shed pieces, and there were also spot losses from large-area foams.

Flight risk management

In a risk-management situation similar to that of the Challenger disaster, NASA management failed to recognize the relevance of engineering concerns for safety and suggestions for imaging to inspect possible damage, and failed to respond to engineers' requests about the status of astronaut inspection of the left wing. Engineers made three separate requests for Department of Defense imaging of the shuttle in orbit to determine damage more precisely. While the images were not guaranteed to show the damage, the capability existed for imaging of sufficient resolution to provide meaningful examination. NASA management did not accede to the requests, and in some cases intervened to stop the DOD from assisting. The CAIB recommended subsequent shuttle flights be imaged while in orbit using ground-based or space-based DOD assets. Details of the DOD's unfulfilled participation with Columbia remain secret; retired NASA official Wayne Hale stated in 2012 that "activity regarding other national assets and agencies remains classified and I cannot comment on that aspect of the Columbia tragedy".
Throughout the risk assessment process, senior NASA managers were influenced by their belief that nothing could be done even if damage were detected. This affected their stance on investigation urgency, thoroughness and possible contingency actions. They decided to conduct a parametric "what-if" scenario study more suited to determine risk probabilities of future events, instead of inspecting and assessing the actual damage. The investigation report in particular singled out NASA manager Linda Ham for exhibiting this attitude. In 2013, Hale recalled that Director of Mission Operations Jon C. Harpold shared with him before Columbias destruction a mindset which Hale himself later agreed was widespread at the time, even among the astronauts themselves:
Much of the risk assessment hinged on damage predictions to the thermal protection system. These fall into two categories: damage to the silica tile on the wing lower surface, and damage to the reinforced carbon-carbon leading-edge panels. The TPS includes a third category of components, thermal insulating blankets, but damage predictions are not typically performed on them. Damage assessments on the thermal blankets can be performed after an anomaly has been observed, and this was done at least once after the return to flight following Columbias loss.
Before the flight NASA believed that the RCC was very durable. Charles F. Bolden, who worked on tile-damage scenarios and repair methods early in his astronaut career, said in 2004 that "never did we talk about because we all thought that it was impenetrable":
Damage-prediction software was used to evaluate possible tile and RCC damage. The tool for predicting tile damage was known as "Crater", described by several NASA representatives in press briefings as not actually a software program but rather a statistical spreadsheet of observed past flight events and effects. The "Crater" tool predicted severe penetration of multiple tiles by the impact if it struck the TPS tile area, but NASA engineers downplayed this. It had been shown that the model overstated damage from small projectiles, and engineers believed that the model would also overstate damage from larger Spray-On Foam Insulation impacts. The program used to predict RCC damage was based on small ice impacts the size of cigarette butts, not larger SOFI impacts, as the ice impacts were the only recognized threats to RCC panels up to that point. Under one of 15 predicted SOFI impact paths, the software predicted an ice impact would completely penetrate the RCC panel. Engineers downplayed this, too, believing that impacts of the less dense SOFI material would result in less damage than ice impacts. In an e-mail exchange, NASA managers questioned whether the density of the SOFI could be used as justification for reducing predicted damage. Despite engineering concerns about the energy imparted by the SOFI material, NASA managers ultimately accepted the rationale to reduce predicted damage of the RCC panels from possible complete penetration to slight damage to the panel's thin coating.
Ultimately the NASA Mission Management Team felt there was insufficient evidence to indicate that the strike was an unsafe situation, so they declared the debris strike a "turnaround" issue and denied the requests for the Department of Defense images.
On January 23, flight director Steve Stich sent an e-mail to Columbia, informing commander Husband and pilot McCool of the foam strike while unequivocally dismissing any concerns about entry safety.

Reentry timeline

Columbia was scheduled to land at 09:16 EST.
at Kirtland Air Force Base.
radar over Texas and Louisiana
In 2008, NASA released a detailed report on survivability aspects of the Columbia reentry. In 2014, NASA released a further report detailing the aeromedical aspects of the disaster. The crew were exposed to five lethal events in the following order:

Depressurization

After the initial loss of control, Columbias cabin pressure remained normal, and the crew were not incapacitated. During this period the crew attempted to regain control of the shuttle. As Columbia spun out of control, aerodynamic forces caused the orbiter to yaw to the right, exposing its underside to extreme aerodynamic forces and causing it to break up. Depressurization began when the shuttle forebody separated from the midbody 41 seconds after loss of control. The crew module pressure vessel was penetrated when it collided with the fuselage, and the "depressurization rate was high enough to incapacitate the crew members within seconds so that they were unable to perform actions such as lowering their visors." The crew lost consciousness, suffering massive pulmonary barotrauma, ebullism and cessation of respiration.

Off-nominal dynamic G environment

The shuttle's separated nose section rotated unsteadily about all three axes. The crew were unable to brace against this motion, and were also harmed by aspects of their protective equipment:
As the crew module disintegrated, the crew received lethal trauma from their seat restraints and were exposed to the hostile aerodynamic and thermal environment of reentry, as well as molten Columbia debris.

Exposure to high-speed and high-altitude environment

After separation from the crew module, the bodies of the crew members entered an environment with almost no oxygen, very low atmospheric pressure, and both high temperatures caused by deceleration, and extremely low ambient temperatures. NASA stated that despite not being certified for those conditions, the ACES suit "may potentially be capable of protecting the crew" above 100,000 feet, although in Columbia's case the crew's suits had already been destroyed by the cabin's thermal environment during breakup. Recovered tissue samples showed evidence of ebullism, indicating the crew was exposed to an altitude above 63,500 feet when depressurization of the cabin occurred.

Ground impact

The bodies of the crew members "had lethal-level injuries caused by ground impact." The official NASA report omitted some of the more graphic details on the recovery of the remains; witnesses reported finds such as a skull, human heart, a portion of an upper torso, and parts of femur bones.
All evidence indicated that crew error was in no way responsible for the disintegration of the orbiter, and they had acted correctly and according to procedure at the first indication of trouble. Although some of the crew were not wearing gloves or helmets during reentry and some were not properly restrained in their seats, doing these things would have added nothing to their survival chances other than perhaps keeping them alive and conscious another 30 or so seconds.

Presidential response

At 14:04 EST, President George W. Bush said, "My fellow Americans, this day has brought terrible news, and great sadness to our country. At 9 o'clock this morning, Mission Control in Houston lost contact with our Space Shuttle Columbia. A short time later, debris was seen falling from the skies above Texas. The Columbia is lost; there are no survivors." Despite the disaster, Bush said, "The cause in which they died will continue...Our journey into space will go on." Bush later declared East Texas a federal disaster area, allowing federal agencies to help with the recovery effort.

Recovery of debris

Debris from the spacecraft was found in more than 2,000 separate fields in eastern Texas, western Louisiana and the southwestern counties of Arkansas. A large amount of debris was recovered between Tyler, Texas, and Palestine, Texas. One field stretched from south of Fort Worth to Hemphill, Texas, and into Louisiana. Places that had debris included Stephen F. Austin State University in Nacogdoches, Texas, and several casinos in Shreveport, Louisiana.
Along with pieces of the shuttle and bits of equipment, searchers also found human body parts, including arms, feet, a torso, and a heart. These recoveries occurred along a line south of Hemphill, Texas and west of the Toledo Bend Reservoir. Much of the terrain being searched for the crew was densely forested and difficult to traverse. The bodies of five of the seven crew of Columbia were found within three days of the shuttle's breakup; the last two were found 10 days after that.
In the months after the disaster, the largest-ever organized ground search took place.
Thousands of volunteers descended upon Texas to participate in the effort to gather the Shuttle's remains. According to Mike Ciannilli, Project Manager of the Columbia Research and Preservation Office, the searchers "put their life on hold to help out the nation's space program," showing "what space means to people."
NASA issued warnings to the public that any debris could contain hazardous chemicals, that it should be left untouched, its location reported to local emergency services or government authorities, and that anyone in unauthorized possession of debris would be prosecuted. Some firefighters used Geiger counters to test those who had picked up debris. These same people were also asked to put their clothes into medical waste bags and use anti-microbial soap. Because of the widespread area, volunteer amateur radio operators accompanied the search teams to provide communications support.
A group of small adult Caenorhabditis elegans worms, living in petri dishes enclosed in aluminum canisters, survived reentry and impact with the ground and were recovered weeks after the disaster. The culture was found to be alive on April 28, 2003. The worms were part of a biological research in canisters experiment designed to study the effect of weightlessness on physiology; the experiment was conducted by Cassie Conley, NASA's planetary protection officer.
Debris Search Pilot Jules F. Mier Jr. and Debris Search Aviation Specialist Charles Krenek died in a helicopter crash that injured three others during the search.
Some Texas residents recovered some of the debris, ignoring the warnings, and attempted to sell it on the online auction site eBay, starting at $10,000. The auction was quickly removed, but prices for Columbia merchandise such as programs, photographs and patches, went up dramatically following the disaster, creating a surge of Columbia-related listings. A three-day amnesty offered for "looted" shuttle debris brought in hundreds of illegally recovered pieces. During the amnesty period, "quite a few" individuals called about turning in property to NASA, including some who had debris from the Challenger accident.
About 40,000 recovered pieces of debris have never been identified. The largest pieces recovered include the front landing gear and a window frame.
On May 9, 2008, it was reported that data from a disk drive on board Columbia had survived the shuttle accident, and while part of the 340 MB drive was damaged, 99% of the data was recovered. The drive was used to store data from an experiment on the properties of shear thinning.
On July 29, 2011, Nacogdoches authorities told NASA that a piece of debris had been found in a lake. NASA identified the piece as a power reactant storage and distribution tank.
All recovered non-human Columbia debris is stored in unused office space at the Vehicle Assembly Building, except for parts of the crew compartment, which are kept separate.

Crew cabin video

Among the recovered items was a videotape recording made by the astronauts during the start of reentry. The 13-minute recording shows the flight crew astronauts conducting routine reentry procedures and joking with each other. None gives any indication of a problem. In the video, the flight-deck crew puts on their gloves and passes the video camera around to record plasma and flames visible outside the windows of the orbiter, a normal occurrence during reentry. At one point on the tape, Mission Control asked Clark to perform some small task. She replied that she was currently occupied but would get to it in a minute. "Don't worry about it," she was told. "You have all the time in the world." The recording, which on normal flights would have continued through landing, ends about four minutes before the shuttle began to disintegrate and 11 minutes before Mission Control lost the signal from the orbiter.

Investigation

Initial investigation

NASA Space Shuttle Program Manager Ron Dittemore reported that "The first indication was loss of temperature sensors and hydraulic systems on the left wing. They were followed seconds and minutes later by several other problems, including loss of tire pressure indications on the left main gear and then indications of excessive structural heating". Analysis of 31seconds of telemetry data which had initially been filtered out because of data corruption within it showed the shuttle fighting to maintain its orientation, eventually using maximum thrust from its Reaction Control System jets.
The investigation focused on the foam strike from the very beginning. Incidents of debris strikes from ice and foam causing damage during take-off were already well known, and had damaged orbiters, most noticeably during STS-45, STS-27, and STS-87. After the loss of Columbia, NASA incorrectly concluded that mistakes during installation were the likely cause of foam loss, and retrained employees at Michoud Assembly Facility in Louisiana to apply foam without defects. Tile damage had also been traced to ablating insulating material from the cryogenic fuel tank in the past.

''Columbia'' Accident Investigation Board

Following protocols established after the loss of, an independent investigating board was created immediately after the accident. The Columbia Accident Investigation Board, or CAIB, was chaired by retired U.S. Navy Admiral Harold W. Gehman, Jr., and consisted of expert military and civilian analysts who investigated the accident in detail.
Columbias flight data recorder was found near Hemphill, Texas, on March 19, 2003. Unlike commercial jet aircraft, the space shuttles did not have flight data recorders intended for after-crash analysis. Instead, the vehicle data were transmitted in real time to the ground via telemetry. Since Columbia was the first shuttle, it had a special flight data OEX recorder, designed to help engineers better understand vehicle performance during the first test flights. The recorder was left in Columbia after the initial Shuttle test-flights were completed, and it was still functioning on the crashed flight. It recorded many hundreds of parameters, and contained very extensive logs of structural and other data, which allowed the CAIB to reconstruct many of the events during the process leading to breakup. Investigators could often use the loss of signals from sensors on the wing to track how the damage progressed. This was correlated with forensic debris analysis conducted at Lehigh University and other tests to obtain a final conclusion about the probable course of events.
Beginning on May 30, 2003, foam impact tests were performed by Southwest Research Institute. They used a compressed air gun to fire a foam block of similar size and mass to that which struck Columbia, at the same estimated speed. To represent the leading edge of Columbias left wing, RCC panels from NASA stock, along with the actual leading-edge panels from , which were fiberglass, were mounted to a simulating structural metal frame. At the beginning of testing, the likely impact site was estimated to be between RCC panel 6 and 9, inclusive. Over many days, dozens of the foam blocks were shot at the wing leading edge model at various angles. These produced only cracks or surface damage to the RCC panels.
During June, further analysis of information from Columbias flight data recorder narrowed the probable impact site to one single panel: RCC wing panel 8. On July 7, in a final round of testing, a block fired at the side of an RCC panel 8 created a hole in that protective RCC panel. The tests demonstrated that a foam impact of the type Columbia sustained could seriously breach the thermal protection system on the wing leading edge.

Conclusions

On August 26, 2003, the CAIB issued its report on the accident. The report confirmed the immediate cause of the accident was a breach in the leading edge of the left wing, caused by insulating foam shed during launch. The report also delved deeply into the underlying organizational and cultural issues that led to the accident. The report was highly critical of NASA's decision-making and risk-assessment processes. It concluded the organizational structure and processes were sufficiently flawed that a compromise of safety was expected, no matter who was in the key decision-making positions. An example was the position of Shuttle Program Manager, where one individual was responsible for achieving safe, timely launches and acceptable costs, which are often conflicting goals. The CAIB report found that NASA had accepted deviations from design criteria as normal when they happened on several flights and did not lead to mission-compromising consequences. One of those was the conflict between a design specification stating that the thermal protection system was not designed to withstand significant impacts and the common occurrence of impact damage to it during flight. The board made recommendations for significant changes in processes and organizational culture.
On December 30, 2008, NASA released a further report, titled Columbia Crew Survival Investigation Report, produced by a second commission, the Spacecraft Crew Survival Integrated Investigation Team. NASA had commissioned this group, "to perform a comprehensive analysis of the accident, focusing on factors and events affecting crew survival, and to develop recommendations for improving crew survival for all future human space flight vehicles." The report concluded that: "The Columbia depressurization event occurred so rapidly that the crew members were incapacitated within seconds, before they could configure the suit for full protection from loss of cabin pressure. Although circulatory systems functioned for a brief time, the effects of the depressurization were severe enough that the crew could not have regained consciousness. This event was lethal to the crew."
The report also concluded:
The key recommendations of the report included that future spacecraft crew survival systems should not rely on manual activation to protect the crew.

Other contributing factors

Upgrades to the leading edge proposed in the early 1990s were not funded because NASA was working on the later-cancelled VentureStar single-stage-to-orbit shuttle replacement. Additionally, the original white paint on the fuel tanks was removed to save, exposing the rust-orange-colored foam; this was considered as a potential contributing factor, but was ultimately unlikely to have contributed to the foam shedding.

Possible emergency procedures

One question of special importance was whether NASA could have saved the astronauts had they known of the danger. This would have to involve either rescue or repair – docking at the International Space Station for use as a haven while awaiting rescue would have been impossible due to the different orbital inclination of the vehicles.
The CAIB determined that a rescue mission, though risky, might have been possible provided NASA management had taken action soon enough. Normally, a rescue mission is not possible, due to the time required to prepare a shuttle for launch, and the limited consumables of an orbiting shuttle. Atlantis was well along in processing for a planned March 1 launch on STS-114, and Columbia carried an unusually large quantity of consumables due to an Extended Duration Orbiter package. The CAIB determined that this would have allowed Columbia to stay in orbit until flight day 30. NASA investigators determined that Atlantis processing could have been expedited with no skipped safety checks for a February 10 launch. Hence, if nothing went wrong, there was a five-day overlap for a possible rescue. As mission control could deorbit an empty shuttle, but could not control the orbiter's reentry and landing, it is likely that it would have sent Columbia into the Pacific Ocean; NASA later developed the Remote Control Orbiter system to permit mission control to land a shuttle.
NASA investigators determined that on-orbit repair by the shuttle astronauts was possible but overall considered "high risk", primarily due to the uncertain resiliency of the repair using available materials and the anticipated high risk of doing additional damage to the Orbiter. Columbia did not carry the Canadarm, or Remote Manipulator System, which would normally be used for camera inspection or transporting a spacewalking astronaut to the wing. Therefore, an unusual emergency extra-vehicular activity would have been required. While there was no astronaut EVA training for maneuvering to the wing, astronauts are always prepared for a similarly difficult emergency EVA to close the external tank umbilical doors located on the orbiter underside, which is necessary for reentry in the event of failure. Similar methods could have reached the shuttle left wing for inspection or repair.
For the repair, the CAIB determined that the astronauts would have to use tools and small pieces of titanium, or other metal, scavenged from the crew cabin. These metals would help protect the wing structure and would be held in place during reentry by a water-filled bag that had turned into ice in the cold of space. The ice and metal would help restore wing leading edge geometry, preventing a turbulent airflow over the wing and therefore keeping heating and burn-through levels low enough for the crew to survive reentry and bail out before landing. The CAIB could not determine whether a patched-up left wing would have survived even a modified reentry, and concluded that the rescue option would have had a considerably higher chance of bringing Columbias crew back alive.

Memorials

On February 2, 2003, and throughout March, April, and May 2003, large memorial Catholic Brazilian masses and Roman Catholic memorial concerts were held in Rio de Janeiro, Sao Paulo, and other cities in Brazil where Brazilian Catholic priest Marcelo Rossi and his concert partner Belo sang a Christian hymn "Noites Traiçoeiras" as tribute to the seven Columbia astronauts, as well as the other seven crew members who lost their lives in the Space Shuttle Challenger disaster in 1986. The concerts were televised to millions throughout Brazil and the world.
On February 4, 2003, President George W. Bush and his wife Laura led a memorial service for the astronauts' families at the Lyndon B. Johnson Space Center. Two days later, Vice President Dick Cheney and his wife Lynne led a similar service at Washington National Cathedral. Patti LaBelle sang "Way Up There" as part of the service.
in Houston, Texas
Spirit
On March 26, the United States House of Representatives' Science Committee approved funds for the construction of a memorial at Arlington National Cemetery for the STS-107 crew. A similar memorial was built at the cemetery for the last crew of. On October 28, 2003, the names of the astronauts were added to the Space Mirror Memorial at the Kennedy Space Center Visitor Complex in Merritt Island, Florida, alongside the names of several astronauts and cosmonauts who have died in the line of duty.
On April 1, 2003, the Opening Day of baseball season, the Houston Astros honored the Columbia crew by having seven simultaneous first pitches thrown by family and friends of the crew. For the National Anthem, 107 NASA personnel, including flight controllers and others involved in Columbias final mission, carried a U.S. flag onto the field. In addition, the Astros wore the mission patch on their sleeves and replaced all dugout advertising with the mission patch logo for the entire season.
On February 1, 2004, the first anniversary of the Columbia disaster, Super Bowl XXXVIII held in Houston's Reliant Stadium began with a pregame tribute to the crew of the Columbia by singer Josh Groban performing "You Raise Me Up", with the crew of STS-114, the first post-Columbia Space Shuttle mission, in attendance.
In 2004, Bush conferred posthumous Congressional Space Medals of Honor to all 14 crew members lost in the Challenger and Columbia accidents.
NASA named several places in honor of Columbia and the crew. Seven asteroids discovered in July 2001 at the Mount Palomar observatory were officially given the names of the seven astronauts: 51823 Rickhusband, 51824 Mikeanderson, 51825 Davidbrown, 51826 Kalpanachawla, 51827 Laurelclark, 51828 Ilanramon, 51829 Williemccool. On Mars, the landing site of the rover Spirit was named Columbia Memorial Station, and included a memorial plaque to the Columbia crew mounted on the back of the high gain antenna. A complex of seven hills east of the Spirit landing site was dubbed the Columbia Hills; each of the seven hills was individually named for a member of the crew, and Husband Hill in particular was ascended and explored by the rover. In 2006, the IAU approved naming of a cluster of seven small craters in the Apollo basin on the far side of the Moon after the astronauts. Back on Earth, NASA's National Scientific Balloon Facility was renamed the Columbia Scientific Balloon Facility.
Other tributes included the decision by Amarillo, Texas, to rename its airport Rick Husband Amarillo International Airport after the Amarillo native. Washington State Route 904 was renamed Lt. Michael P. Anderson Memorial Highway, as it runs through Cheney, Washington, the town where he graduated from high school. A newly constructed elementary school located on Fairchild Air Force Base near Spokane, Washington, was named Michael Anderson Elementary School. Anderson had attended fifth grade at Blair Elementary, the base's previous elementary school, while his father was stationed there. A mountain peak near Kit Carson Peak and Challenger Point in the Sangre de Cristo Range was renamed Columbia Point, and a dedication plaque was placed on the point in August 2003. Seven dormitories were named in honor of Columbia crew members at the Florida Institute of Technology, Creighton University, The University of Texas at Arlington, and the Columbia Elementary School in the Brevard County School District. The Huntsville City Schools in Huntsville, Alabama, a city strongly associated with NASA, named their most recent high school Columbia High School as a memorial to the crew. A Department of Defense school in Guam was renamed Commander William C. McCool Elementary School. The City of Palmdale, California, the birthplace of the entire shuttle fleet, changed the name of the thoroughfare Avenue M to Columbia Way. In Avondale, Arizona, the Avondale Elementary School where Michael Anderson's sister worked had sent a T-shirt with him into space. It was supposed to have an assembly when he returned from space. The school was later renamed Michael Anderson Elementary.
The first dedicated meteorological satellite launched by the Indian Space Research Organisation on September 2, 2002, named Metsat-1, was later renamed Kalpana-1 by Indian Prime Minister Atal Bihari Vajpayee in memory of India-born Kalpana Chawla.
In October 2004, both houses of Congress passed a resolution authored by U.S. Representative Lucille Roybal-Allard and co-sponsored by the entire contingent of California representatives to Congress changing the name of Downey, California's Space Science Learning Center to the Columbia Memorial Space Science Learning Center. The facility is located at the former manufacturing site of the space shuttles, including Columbia and Challenger.
The U.S. Air Force's Squadron Officer School at Maxwell Air Force Base, Alabama, renamed their auditorium in Husband's honor. He was a graduate of the program. The U.S. Test Pilot School at Edwards Air Force Base in California named its pilot lounge for Husband.
NASA named a supercomputer "Columbia" in the crew's honor in 2004. It was located at the NASA Advanced Supercomputing Division at Ames Research Center on Moffett Federal Airfield near Mountain View, California. The first part of the system, built in 2003, known as "Kalpana" was dedicated to Chawla, who worked at Ames prior to joining the Space Shuttle program.
A U.S. Navy compound at a major coalition military base in Afghanistan is named Camp McCool. In addition, the athletic field at McCool's alma mater, Coronado High School in Lubbock, Texas, was renamed the Willie McCool Track and Field.
A proposed reservoir in Cherokee County in Eastern Texas is to be named Lake Columbia.
Ilan Ramon High School was established in 2006 in Hod HaSharon, Israel, in tribute to the first Israeli astronaut. The school's symbol shows the planet Earth with an aircraft orbiting around it.
The National Naval Medical Center dedicated Laurel Clark Memorial Auditorium on July 11, 2003. Gamma Phi Beta sorority, of which Clark was a member, created the Laurel Clark Foundation in her honor. A fountain in downtown Racine, Wisconsin, which Clark considered her hometown, was named for her.
PS 58 in Staten Island, New York, was named Space Shuttle Columbia School in honor of the failed mission.
The Challenger Columbia Stadium in League City, Texas is named in honor of the victims of both the Columbia disaster as well as the Challenger disaster in 1986.
A tree for each astronaut was planted in NASA's Astronaut Memorial Grove at the Johnson Space Center in Houston, Texas, not far from the Saturn V building, along with trees for each astronaut from the Apollo 1 and Challenger disasters. Tours of the space center pause briefly near the grove for a moment of silence, and the trees can be seen from nearby NASA Road 1.
Columbia Colles, a range of hills on Pluto discovered by the New Horizons spacecraft in July 2015, was named in honor of the victims of the disaster.
A starship on was named NX-02 Columbia in honor of the Columbia.
A photo tribute commemorating the Columbia and its crew is displayed in the "Wings of Fame" section of the queue for Soarin' Around the World at Disney California Adventure park alongside many other famous air and space craft.
The Columbia Memorial Space Center is a museum built in honor of the Columbia in Downey, California.
At the 2003 Daytona 500, which happened 2 weeks after the disaster, all racecars bore Columbia decals in honor of those who were lost.

Effect on space programs

Following the loss of Columbia, the space shuttle program was suspended. The further construction of the International Space Station was also delayed, as the space shuttles were the only available delivery vehicle for station modules. The station was supplied using Russian uncrewed Progress ships, and crews were exchanged using Russian-crewed Soyuz spacecraft, and forced to operate on a skeleton crew of two.
Less than a year after the accident, President Bush announced the Vision for Space Exploration, calling for the space shuttle fleet to complete the ISS, with retirement by 2010 following the completion of the ISS, to be replaced by a newly developed Crew Exploration Vehicle for travel to the Moon and Mars. NASA planned to return the space shuttle to service around September 2004; that date was pushed back to July 2005.
On July 26, 2005, at 10:39 EST, Space Shuttle Discovery cleared the tower on the "Return to Flight" mission STS-114, marking the shuttle's return to space. Overall the STS-114 flight was highly successful, but a similar piece of foam from a different portion of the tank was shed, although the debris did not strike the Orbiter. Due to this, NASA once again grounded the shuttles until the remaining problem was understood and a solution implemented. After delaying their reentry by two days due to adverse weather conditions, Commander Eileen Collins and Pilot James M. Kelly returned Discovery safely to Earth on August 9, 2005. Later that same month, the external tank construction site at Michoud was damaged by Hurricane Katrina. At the time, there was concern that this would set back further shuttle flights by at least two months and possibly more.
The actual cause of the foam loss on both Columbia and Discovery was not determined until December 2005, when x-ray photographs of another tank showed that thermal expansion and contraction during filling, not human error, caused cracks that led to foam loss. NASA's Hale formally apologized to the Michoud workers who had been blamed for the loss of Columbia for almost three years.
The second "Return to Flight" mission, STS-121, was launched on July 4, 2006, at 14:37:55, after two previous launch attempts were scrubbed because of lingering thunderstorms and high winds around the launch pad. The launch took place despite objections from its chief engineer and safety head. This mission increased the ISS crew to three. A crack in the foam insulation of the external tank gave cause for concern, but the Mission Management Team gave the go for launch. Space Shuttle Discovery touched down successfully on July 17, 2006, at 09:14:43 on Runway 15 at the Kennedy Space Center.
On August 13, 2006, NASA announced that STS-121 had shed more foam than they had expected. While this did not delay the launch for the next mission—STS-115, originally set to lift off on August 27 —the weather and other technical glitches did, with a lightning strike, Hurricane Ernesto and a faulty fuel tank sensor combining to delay the launch until September 9. On September 19, landing was delayed an extra day to examine Atlantis after objects were found floating near the shuttle in the same orbit. When no damage was detected, Atlantis landed successfully on September 21.
The Columbia Crew Survival Investigation Report released by NASA on December 30, 2008, made further recommendations to improve a crew's survival chances on future space vehicles, such as the then planned Orion spacecraft. These included improvements in crew restraints, finding ways to deal more effectively with catastrophic cabin depressurization, more "graceful degradation" of vehicles during a disaster so that crews will have a better chance at survival, and automated parachute systems.
The United States ended its Space Shuttle program in 2011 in part due to the fallout from the Columbia disaster. No further crewed spacecraft were launched from American soil to the ISS until 2020 when SpaceX's Crew Dragon Demo-2 mission successfully carried a test crew of two NASA astronauts to the International Space Station.

Sociocultural aftermath

Fears of terrorism

After the shuttle's breakup, there were some initial fears that terrorists might have been involved, but no evidence of that has ever surfaced. Security surrounding the launch and landing of the space shuttle had been increased because the crew included the first Israeli astronaut. The Merritt Island launch facility, like all sensitive government areas, had increased security after the September 11 attacks.

Purple streak image

The San Francisco Chronicle reported that an amateur astronomer had taken a five-second exposure that appeared to show "a purplish line near the shuttle", resembling lightning, during reentry. The CAIB report concluded that the image was the result of "camera vibrations during a long-exposure".

2003 ''Armageddon'' film hoax

In response to the disaster, FX canceled its scheduled airing two nights later of the 1998 film Armageddon, in which the is depicted as being destroyed by asteroid fragments. In a hoax inspired by the destruction of Columbia, some images that were purported to be satellite photographs of the Shuttle's "explosion" turned out to be screen captures from the Space Shuttle destruction scene of Armageddon.

Music

The 2003 album Bananas by Deep Purple includes "Contact Lost", an instrumental piece written by guitarist Steve Morse in remembrance of the loss. Morse is donating his songwriting royalties to the families of the astronauts.
Catherine Faber and Callie Hills included a memorial song titled "Columbia" on their 2004 album From the Hazel Tree.
The 2005 album Ultimatum by The Long Winters contains the song "The Commander Thinks Aloud", which was songwriter/singer John Roderick's musing on the crew's perspective of the unexpected catastrophe. In addition, the January 30, 2015 episode of Hrishikesh Hirway's Song Exploder podcast presented an interview with John Roderick about the songwriting and recording process for "The Commander Thinks Aloud".
The Hungarian composer Peter Eötvös wrote a piece named Seven for solo violin and orchestra in 2006 in memory of the crew of Columbia. Seven was premiered in 2007 by violinist Akiko Suwanai, conducted by Pierre Boulez, and it was recorded in 2012 with violinist Patricia Kopatchinskaja and the composer conducting.
The 2008 album Columbia: We Dare to Dream by Anne Cabrera was written as a tribute to Space Shuttle Columbia STS-107, the crew, support teams, recovery teams, and the crew's families. A copy of the album on compact disc was flown aboard mission STS-131 to the International Space Station by astronaut Clayton Anderson in April 2010.
The Scottish Folk-Rock band Runrig included a song titled "Somewhere" on their album The Story ; the song was dedicated to Laurel Clark, and includes a piece of her wake up song, followed by some radio chatter, at the end.