Jet pack
A jet pack, rocket belt, or rocket pack is a device worn on the back which uses jets of gas or liquid to propel the wearer through the air. The concept has been present in science fiction for almost a century and became widespread in the 1960s. Real jet packs have been developed using a variety of mechanisms, but their uses are much more limited than their fictional counterparts because of the challenges of the Earth's atmosphere, gravity, the low energy density of utilisable fuels, and the human body not being suited to flight, and they are principally used for stunts. A practical use for the jet pack has been in extra-vehicular activities for astronauts due to apparent weightlessness and lack of friction-creating atmosphere in orbit.
Overview
In the most general terms, a jet pack is a wearable device which allows the user to fly by providing thrust. With the exception of use in a microgravity environment, this thrust must be upwards so as to overcome the force of gravity, and must be enough to overcome the weight of the user, the jet pack itself and its fuel. This necessarily requires the jet pack to continually push mass in a downwards direction.While some designs have power and/or mass supplied from an external, ground-based source, untethered flight requires all of a flight's fuel to be carried within the pack. This results in problems relating to the overall mass ratio, which limits the maximum flight time to tens of seconds, rather than the sustained flight envisaged in science fiction.
Liquid-fuelled rocket pack
Andreyev: oxygen-and-methane, with wings
The first pack design was developed in 1919 by the Russian inventor Alexander F. Andreev. The project was well regarded by Nikolai Rynin and technology historians Yu. V. Biryukov and S. V. Golotyuk. Later it was issued a patent but apparently was not built or tested. It was oxygen-and-methane-powered with wings each roughly long.Hydrogen peroxide-powered rocket packs
A hydrogen peroxide-powered engine is based on the decomposition reaction of hydrogen peroxide. Nearly pure hydrogen peroxide is used. Pure hydrogen peroxide is relatively stable, but in contact with a catalyst it decomposes into a mixture of superheated steam and oxygen in less than 1/10 millisecond, increasing in volume 5,000 times: 2 H2O2 → 2 H2O + O2. The reaction is exothermic, i.e., accompanied by the liberation of much heat, forming in this case a steam-gas mixture at. This hot gas is used exclusively as the reaction mass and is fed directly to one or more jet nozzles.The great disadvantage is the limited operating time. The jet of steam and oxygen can provide significant thrust from fairly lightweight rockets, but the jet has a relatively low exhaust velocity and hence a poor specific impulse. Currently, such rocket belts can only fly for about 30 seconds.
A more conventional bipropellant could more than double the specific impulse. However, although the exhaust gases from the peroxide-based engine are very hot, they are still significantly cooler than those generated by alternative propellants. Using a peroxide-based propellant greatly reduces the risk of a fire/explosion which would cause severe injury to the operator.
In contrast to, for example, turbojet engines, which mainly expel atmospheric air to produce thrust, rocket packs are far simpler to build than devices using turbojets. The classical rocket pack construction of Wendell Moore can be made under workshop conditions, given good engineering training and a high level of tool-making craftsmanship.
The main disadvantages of this type of rocket pack are:
- Short duration of flight.
- The high expense of the peroxide propellant.
- The inherent dangers of flying below minimum parachute altitude, and hence without any safety equipment to protect the operator if there is an accident or malfunction.
- Safely learning how to fly it, given that there are no dual-control training versions.
- The sheer difficulty of manually flying such a device.
Justin Capră's flying backpack
claimed that he invented a "flying rucksack" in 1956 in Romania, and, without arousing any apparent interest, informed the American Embassy of his idea. In 1962 a backpack was created at Bell Laboratories, following Justin Capră's prototype. The backpack is now displayed in a museum where it's kept safe.Jump Belt
In 1958, Garry Burdett and Alexander Bohr, Thiokol Corporation engineers, created a Jump Belt which they named Project Grasshopper. Thrust was created by high-pressure compressed nitrogen. Two small nozzles were affixed to the belt and directed vertically downward. The wearer of the belt could open a valve, letting out nitrogen from the gas cylinder through the nozzles, which tossed him upward to a height of. After leaning forward, it was possible with the aid of the jump belt's thrust to run at. Later, Burdett and Bohr tested a hydrogen peroxide-powered version. The jump belt was demonstrated by a serviceman in action, but as no financing was forthcoming, there was no further testing.Aeropack
In 1959 Aerojet General Corporation won a U.S. Army contract to devise a jet pack or rocket pack. At the start of 1960 Richard Peoples made his first tethered flight with his Aeropack.U.S. Army interest
The military did not lose interest in this type of flight vehicle. Transport studies of the U.S. Army Transportation Research Command determined that personal jet devices could have diverse uses: for reconnaissance, crossing rivers, amphibious landing, accessing steep mountain slopes, overcoming minefields, tactical maneuvering, etc. The concept was named "Small Rocket Lift Device", SRLD.Within the framework of this concept the administration concluded a big contract with the Aerojet General company in 1959 to research the possibility of designing an SRLD suitable for army purposes. Aerojet came to the conclusion that the version with the engine running on hydrogen peroxide was most suitable. However, it soon became known to the military that engineer Wendell F. Moore of the Bell Aerosystems company had for several years been carrying out experiments to make a personal jet device. After becoming acquainted with his work, servicemen during August 1960 decided to commission Bell Aerosystems with developing an SRLD. Wendell Moore was appointed chief project engineer.
Bell Textron Rocket Belt
In 1960, the Bell Rocketbelt was presented to the public. The jet of gas was provided by a hydrogen peroxide-powered rocket, but the jet could also be provided by a turbojet engine, a ducted fan, or other kinds of rockets powered by solid fuel, liquid fuel or compressed gas.This is the oldest known type of jet pack or rocket pack. One Bell Rocket Belt is on display at the Smithsonian Institution's National Air and Space Museum annex, the Steven F. Udvar-Hazy Center, located near Dulles Airport.
RB-2000 Rocket Belt
This was a successor to the Bell Rocket Belt.Bell Pogo
The Bell Pogo was a small rocket-powered platform that two people could ride on. Its design used features from the Bell Rocket Belt.Powerhouse Productions Rocketbelt
More commonly known as "The Rocketman", Powerhouse Productions, owned and operated by Kinnie Gibson, manufactures the 30 second flying Rocketbelt and organizes Rocketbelt performances. Since 1983 Powerhouse Productions has performed show flights in over 40 countries such as the Carnival in Rio de Janeiro, Super Bowls, the Rose Parade, Daytona 500, and the Michael Jackson Dangerous World Tour, as well as many television shows including Walker, Texas Ranger, The Fall Guy and NCIS. Powerhouse Rocketbelt pilots include stuntman Kinnie Gibson and Dan Schlund.Jetpack International
Jetpack International made three types of wingless jet packs:| Name | Max flight time | Max distance | Max speed | Max height | Max pilot weight | Fuel | Engine type | Fuel capacity | Price |
| Jet pack H202 | 23 seconds | hydrogen peroxide | rocket | Not for sale | |||||
| Jet pack H202-Z | 33 seconds | hydrogen peroxide | rocket | Not for sale | |||||
| Jet pack T-73 | ~9 minutes | c. | ~ | ~ | Jet-A fuel | T-73 jet engine | $200,000 |
A Jet Pack H202 was flown for 34 seconds in Central Park on the 9 April 2007 episode of the Today Show and sold for $150,000. As of January 2009 their H202 jet packs are for demonstration only, not for sale. Details of the likely consumer model "Falcon" were scheduled for an official announcement on May 1, 2012, but the company is currently behind schedule.
Current technology
At the TechCrunch Disrupt conference in 2014, Astro Teller, head of Google X, said they investigated jetpacks but found them too inefficient to be practical, with fuel consumption as high as, and were as loud as a motorcycle, so they decided not to pursue developing them.In recent years, the rocket pack has become popular among enthusiasts, and some have built them for themselves. The pack's basic construction is rather simple, but its flying capability depends on two key parts: the gas generator, and the thrust control valve. The rocket packs being built today are largely based on the research and inventions of Wendell Moore at Bell Helicopter.
One of the largest stumbling blocks that would-be rocket pack builders have faced is the difficulty of obtaining concentrated hydrogen peroxide, which is no longer produced by many chemical companies. The few companies that produce high-concentration hydrogen peroxide only sell to large corporations or governments, forcing some amateurs and professionals to set up their own hydrogen peroxide distillation installations. High-concentration hydrogen peroxide for rocket belts was produced by Peroxide Propulsion from 2004 to 2010, but after a serious accident Peroxide Propulsion stopped making it.
Turbojet packs
Packs with a turbojet engine are fueled with traditional kerosene-based jet fuel. They have higher efficiency, greater height and a duration of flight of many minutes, but they are complex in construction and very expensive. Only one working model of this pack was made; it underwent flight tests in the 1960s and at present it no longer flies.Jet packs and rocket packs have much better flight time on a tankful of fuel if they have wings like an aeroplane's.
Bell Jet Flying Belt: wingless
In 1965 Bell Aerosystems concluded a new contract with the Defense Advanced Research Projects Agency to develop a jet pack with a turbojet engine. This project was called the "Jet Flying Belt", or simply the "Jet Belt". Wendell Moore and John K. Hulbert, a specialist in gas turbines, worked to design a new turbojet pack. Williams Research Corporation in Walled Lake, Michigan, designed and built a new turbojet engine to Bell's specifications in 1969. It was called the WR19, had a rated thrust of and weighed. The Jet Belt first flew free on 7 April 1969 at the Niagara Falls Municipal Airport. Pilot Robert Courter flew about in a circle at an altitude of, reaching a speed of. The following flights were longer, up to 5 minutes. Theoretically, this new pack could fly for 25 minutes at velocities up to.In spite of successful tests, the U.S. Army lost interest. The pack was complex to maintain and too heavy. Landing with its weight on their back was hazardous to the pilot, and catastrophic loss of a turbine blade could have been lethal.
Thus, the Bell Jet Flying Belt remained an experimental model. On 29 May 1969, Wendell Moore died of complications from a heart attack he had suffered six months earlier, and work on the turbojet pack was ended. Bell sold the sole version of the "Bell pack", together with the patents and technical documentation, to Williams Research Corporation. This pack is now in the Williams International company museum.
The "Jet Belt" used a small turbofan engine which was mounted vertically, with its air intake downward. Intake air was divided into two flows. One flow went into the combustion chamber, the other flow bypassed the engine, then mixed with the hot turbine gases, cooling them and protecting the pilot from the high temperatures generated. In the upper part of the engine the exhaust was divided and entered two pipes which led to jet nozzles. The construction of the nozzles made it possible to move the jet to any side. Kerosene fuel was stored in tanks beside the engine. Control of the turbojet pack was similar to the rocket pack, but the pilot could not tilt the entire engine. Maneuvering was by deflecting the nozzles. By inclining levers, the pilot could move the jets of both nozzles forward, back, or sideways. The pilot rotated left/right by turning the left handle. The right handle governed the engine thrust. The jet engine was started with the aid of a powder cartridge. While testing this starter, a mobile starter on a special cart was used. There were instruments to control the power of the engine, and a portable radio to connect and transmit telemetry data to ground-based engineers. On top of the pack was a standard auxiliary landing parachute; it was effective only when opened at altitudes above. This engine was later the basis for the propulsion units of Tomahawk and other cruise missiles.
Visa Parviainen's jet-assisted wingsuit
On 25 October 2005 in Lahti in Finland, Visa Parviainen jumped from a hot air balloon in a wingsuit with two small turbojet jet engines attached to his feet. Each turbojet provided approximately of thrust and ran on kerosene fuel. Parviainen apparently achieved approximately 30 seconds of horizontal flight with no noticeable loss of altitude.Yves Rossy's jet wingpack
Swiss ex-military and commercial pilot Yves Rossy developed and built a winged pack with rigid aeroplane-type carbon-fiber wings spanning about and four small kerosene-burning Jetcat P400 jet engines underneath; these engines are large versions of a type designed for model aeroplanes. He wears a heat-resistant suit similar to that of a firefighter or racing driver to protect him from the hot jet exhaust. Similarly, to further protect the wearer, the engines are modified by adding a carbon fiber heat shield extending the jet nozzle around the exhaust tail.Rossy claims to be "the first person to gain altitude and maintain a stable horizontal flight thanks to aerodynamic carbon foldable wings", which are folded by hinges at their midpoint. After being lifted to altitude by a plane, he ignites the engines just before he exits the plane with the wings folded. The wings unfold while in free-fall, and he then can fly horizontally for several minutes, landing with the help of a parachute. He achieves true controlled flight using his body and a hand throttle to maneuver; jet wingsuits use small turbojets, but differ from other aircraft in that the fuselage and flight control surfaces consist of a human.
The system is said by Rossy to be highly responsive and reactive in flight, to the point where he needs to closely control his head, arm and leg movements to avoid an uncontrolled spin. The engines on the wing must be aligned precisely during set-up, also to prevent instability. An electronic starter system ensures that all four engines ignite simultaneously. In the event of a spin, the wing unit can be detached from the pilot, and pilot and wing unit descend to Earth separately, each with a parachute.
Since 2007, Rossy has conducted some of his flight tests from a private airfield, Skydive Empuriabrava, in Empuriabrava, Spain. Rossy's jet pack was exhibited on 18 April 2008 on the opening day of the 35th Exhibition of Inventions at Geneva. Rossy and his sponsors spent over $190,000 to build the device. His first successful trial flight was on 24 June 2004 near Geneva, Switzerland. Rossy has made more than 30 powered flights since. In November 2006 he flew with a later version of his jet pack. On 14 May 2008 he made a successful 6-minute flight from the town of Bex near Lake Geneva. He exited a Pilatus Porter at with his jet pack. It was the first public demonstration before the world's press. He made effortless loops from one side of the Rhone valley to the other and rose.
It has been claimed that the military was impressed and asked for prototypes for the powered wings, but that Rossy kindly refused the request stating that the device was only intended for aviation enthusiasts.
On 26 September 2008, Yves successfully flew across the English Channel from Calais, France, to Dover, England, in 9 minutes, 7 seconds. His speed reached during the crossing and was when he deployed the parachute.
Since then he has—in several flights—managed to fly in a formation with three military jets and cross the Grand Canyon, but he failed to fly across the Strait of Gibraltar—he made an emergency landing in the water.
On 13 October 2015 a show flight was performed in Dubai. Two jet packs operated by Rossy and Vince Reffet flew in formation with an Airbus A380 jetliner.
Troy Hartman: jetpack and parafoil
In 2008 Troy Hartman started designing a wingless jetpack with two turbojet motors strapped to his back; later he added a parafoil as a wing.Fritz Unger: jetpack with rigid wings
As of 2013 Fritz Unger in Germany is developing a jetpack called Skyflash with rigid wings about wingspan and two turbojets designed to run on diesel fuel. It is designed for takeoff from the ground using four undercarriage wheels on the front of his chest and abdomen.JetPack Aviation: Wingless Jetpack
On 3 November 2015, Jetpack Aviation demonstrated the JB-9 in Upper New York Bay in front of the Statue of Liberty. The JB-9 carries of kerosene fuel that burns through two vectored thrust AMT Nike jet engines at a rate of per minute for up to ten minutes of flying time, depending on pilot weight. Weight of fuel is a consideration, but it is reported to start with per minute climb rate that doubles as the fuel burns off. While this model has been limited to, the prototype of the JB-10 is reported to fly at over.This is a true jetpack: a backpack that provides jet-powered flight. Most of the volume is the fuel tank, with twin turbine jet engines gimbal-mounted on each side. The control system is identical to the Bell Rocket Belt: tilting the handgrips vectors the thrust – left-right & forward-back – by moving the engines; twisting left hand moves two nozzle skirts for yaw; twisting the right hand counterclockwise increases throttle. Jetpack Aviation was started by Australian businessman David Mayman with the technical knowhow coming from Nelson Tyler, prolific inventor of helicopter-mounted camera stabilizers and one of the engineers that worked on the Bell Rocketbelt that was used in the 1984 Olympics.
Flyboard Air
, invented by Franky Zapata, allows flight up to and has a top speed of. It also has 10 minutes autonomy. Zapata participated with his invention during the 2019 Bastille Day military parade. He also attempted to cross the English channel with his device, which succeeded during the second try on 4 August 2019.Daedalus Flight Pack
This particular innovation saw two jets attached to the back of an exoskeleton, worn by the operator. At the same time, two additional jets were added to the arms, and could be moved with the arms to control movement. It was devised by Richard Browning of Gravity Industries.Government
Space
Rocket packs can be useful for spacewalks. While near Earth a jet pack has to produce a g-force of at least 1g, for excursions outside a free falling spaceship, a small g-force providing a small deviation from free fall is quite useful. Hence much less delta-v is consumed per unit time, and not during the whole EVA. With only small amounts of thrust needed, safety and temperature are much more manageable than in the atmosphere in Earth's gravity field.Nevertheless, it is currently worn to be used only in case of emergency: the Simplified Aid For EVA Rescue.
Firefighters
Firefighters in some parts of the world use Jet packs which help them to fight fires close to the sea or a water body. The jet packs use water and there is no need for a fire truck or water tank.Hydrojet packs
The 21st century has seen a new approach to jet packs where water is used as a high-density propulsion fluid. This requires a very large mass of fluid that makes a self-contained jetpack infeasible. Instead, this approach separates the engine, fuel and fluid supply from the pilot's flying apparatus, using a long flexible hose to feed the water to the jet nozzle pack attached to the pilot's body. These inventions are known as "hydro jet packs", and successful designs have used jetski technology as the powerplant operating in a body of water to provide the needed propulsion. Several hydro jet pack approaches have been successfully tested and put into production. Flow rate can be controlled by a throttle operator on the jetski, or by the pilot using a remote actuator.Another significant difference with hydro jet packs is that they can be operated below the surface as well as above it. As of 2013, many hydro jet pack rental businesses are operating in various locations around the world.
JetLev
The JetLev was the first hydroflight jetpack on the market, and its makers were awarded the first patents, in 2008, for hydrojetpacks. The JetLev has the appearance of a typical jet pack, with two nozzles on a backpack propelling the rider upwards. It just has an umbilicus to the powering jetski that provides the water for the thrust used.Flyboard
A Flyboard has water jets under each of the pilot's feet. An optional feature is a lower-thrust water jet for each arm for greater control. The powerplant is a regular jetski. Development for this approach was started in the spring of 2011.Home-made versions
of MythBusters investigates the urban legend of an affordable jet pack or rocket pack that can be built from plans purchased on the Internet. Extensive modifications were made by the MythBusters team due to vagueness in the plans and because of the infeasibility of the specified engine mounting system. The jet pack produced by the MythBusters had two ducted fans powered by ultralight-type piston engines. They found it was not powerful enough to lift a person off the ground, and was expensive to build. The plans specified a Rotax 503 ultralight engine, but they intended to use the more powerful and lighter Rotax 583 engine before a similar lighter unnamed engine was substituted.In fiction
The concept of jet packs appeared in popular culture, particularly science fiction, long before the technology became practical. Perhaps the first appearance was in pulp magazines. The 1896 novel The Country of the Pointed Firs mentions a "fog-shaped" man hovering low with a "the look of a pack on his back" who "flittered away out o' sight like a leaf the wind takes with it". The 1928 cover of Amazing Stories featured a man flying with a jet pack.When Republic Pictures planned to produce a superhero serial using its renowned "flying man" scenes as used in The Adventures of Captain Marvel, the character of Captain Marvel was tied up in litigation with the owners of the character of Superman. For its postwar superhero serial, Republic used a jet pack in King of the Rocket Men. The same stock special effects were used in other serials.
While several science fiction novels from the 1950s featured jetpacks, it was not until the Bell Rocket Belt in the 1960s that the jet pack caught the imagination of the mainstream. Bell's demonstration flights in the U.S. and other countries created significant public enthusiasm.
Jetpacks were featured in two episodes, of the original Jonny Quest animated television series, and are seen at the end of the closing credits.
In 1965 a jetpack appeared in the James Bond movie Thunderball when James Bond played by Sean Connery used a jet pack in the pre-title sequence to escape the villains and rendezvous with his French contact. The pack was piloted by Gordon Yaeger and Bill Suitor.
In the Irwin Allen television series Lost in Space, a jetpack was used by members of the Jupiter II expedition on several occasions.
In 1966 the plot of the 21st book in the Rick Brant series titled Rocket Jumper was based on a hydrogen peroxide fueled jet pack, The book included a relatively detailed description of the design including use of a platinum-metal screen catalyst.
In the 1997 video game, the titular character Crash operates a jetpack in two main levels: "Rock It" and "Pack Attack". He also uses the jetpack in the final boss fight against Dr. Neo Cortex.
The 1976 television series Ark II featured a jetpack called the Jet Jumper.
In the Star Wars original trilogy, the bounty hunter Boba Fett used a jet pack. In the prequel trilogy, Jango Fett also used a jet pack.
In the 1982-1995 comics book series, The Rocketeer, the protagonist, Cliff Secord, acquires a stolen military jet pack and uses it to become the eponymous superhero. It was later adapted into a motion picture in 1991.
The G.I. Joe action figure launch in 1982 included the JUMP jet pack as an accessory. It was also featured prominently in the related G.I. Joe comic book series and cartoon.
Jetpacks have been used by the title characters in several episodes of SWAT Kats cartoon series.
In the Toy Story franchise, Buzz Lightyear also used a jet pack.
Jetpacks appear in the popular video game '. The jet-pack also appears in the 2012 video game Halo 4, developed by 343 Industries.
Jetpacks also appeared in other video games, including Duke Nukem 3D, BloodRayne, Tribes, ', Armed and Dangerous, and the Pilotwings series, in which it is referred to as a "Rocket Belt". It is also accessible in the video game '. Fallout 4 also has a jetpack power armor feature. Grand Theft Auto Online added a jetpack called "Thruster" as an usable vehicle on a content update on December 12, 2017. Rocketeer is Allied flying infantry unit in '
Many science fiction movies have included jet packs, most notably Minority Report, Sky Captain and the World of Tomorrow, and Tomorrowland.
Running since 2013, Adventures in Jetpacks is a semi-regularly updated webcomic in which the cast of characters make regular use of Jet packs.