B Reactor
The B Reactor at the Hanford Site, near Richland, Washington, was the first large-scale nuclear reactor ever built. The project was commissioned to produce plutonium-239 by neutron activation as part of the Manhattan Project, the United States nuclear weapons development program during World War II. The B reactor was fueled with metallic natural uranium, graphite moderated, and water-cooled. It has been designated a U.S. National Historic Landmark since August 19, 2008 and in July 2011 the National Park Service recommended that the B Reactor be included in the Manhattan Project National Historical Park commemorating the Manhattan Project. Visitors can take a tour of the reactor by advance reservation.
Reactor design and construction
The reactor was designed and built by E. I. du Pont de Nemours and Company based on experimental designs tested by Enrico Fermi at the University of Chicago, and tests from the X-10 Graphite Reactor at Oak Ridge National Laboratory. It was designed to operate at 250 megawatts.The reactor occupies a footprint of , sealed in aluminum cans, and loaded into the aluminum tubes.
The reactor was water-cooled, with cooling water pumped from the Hanford Reach of the Columbia River through the aluminum tubes around the uranium slugs at the rate of per minute. The water was discharged into settling basins, then returned to the river after allowing time for the decay of radioactive materials, the settling out of particulate matter and for the water to cool so it could be returned to the Columbia River. Water returning to the river was prohibited from raising the temperature of the river by more than 11 °F.
with the B/C reactor site shown at the upper left.
Reactor operation
The B Reactor had its first nuclear chain reaction in September, 1944, the D Reactor in December 1944 and the F Reactor in February 1945. The reactor produced plutonium-239 by irradiating uranium-238 with neutrons generated by the nuclear reaction. It was one of three reactors - along with the D and F reactors - built about six miles apart on the south bank of the Columbia River. Each reactor had its own auxiliary facilities that included a river pump house, large storage and settling basins, a filtration plant, large motor-driven pumps for delivering water to the face of the pile, and facilities for emergency cooling in case of a power failure.Emergency shutdown of the reactor, referred to as a SCRAM, was attained either by rapidly fully inserting the vertical safety rods or, as a backup method, by the injection of borated water into the reactor. In January 1952, the borated water system was replaced by a "Ball-3X" system that injected nickel-plated high-boron steel balls into the channels occupied by the vertical safety rods.
The plutonium for the nuclear bomb used in the Trinity test in New Mexico and the Fat Man bomb dropped on Nagasaki, Japan was created in the B reactor. B reactor ran for two decades, and was joined by additional reactors constructed later. The B Reactor was permanently shut down in February 1968.
Current status
The United States Department of Energy has administered the site since 1977 and offers public tours on set dates during the spring, summer, and fall of the year, as well as special tours for visiting officials.six of the nine production reactors at Hanford were considered to be in "interim safe storage" status, and two more were to receive similar treatment. The exception was the B Reactor, which was given special status for its historical significance.
In a process called cocooning or entombment, the reactor buildings are demolished up to the concrete shield around the reactor core. Any openings are sealed and a new roof is built. Most auxiliary buildings at the first three reactors have been demolished, as well.
The C reactor was put into operation in 1952 and was shut down in 1969. It was cocooned as of 1998.
The D reactor operated from 1944 to June 1967, and was cocooned in 2004. The DR Reactor went online in October 1950, and was shut down in 1964. It was cocooned in 2002.
The F reactor was shut down in June 1965 and cocooned in 2003.
The H Reactor became operational as of October 1949 and was shut down as of April 1965. It was cocooned as of 2005.
Cocooning of the N-Reactor, which operated from 1963 to 1987, was completed as of June 14, 2012.
The decommissioned reactors are inspected every five years by the Department of Energy.
The K East and K West reactors were built in the 1950s and went into use in 1955. They were shut down in 1970 and 1971, but reused temporarily for storage later.
Preliminary plans for interim stabilizing of the K-East and K-West reactors were underway as of January 30, 2018.
The B Reactor was added to the National Register of Historic Places on April 3, 1992. A Record of Decision was issued in 1999, and an EPA Action Memorandum in 2001 authorized hazards mitigation in the reactor with the intention of allowing public tours of the reactor. It was named a National Historic Landmark on August 19, 2008.
In December 2014, passage of the 2015 National Defense Authorization Act made the B reactor part of the Manhattan Project National Historical Park, which also includes historic sites at Oak Ridge, Tennessee and Los Alamos, New Mexico. The park was formally established by a Memorandum of Agreement on November 10, 2015, which was signed by the National Park Service and the Department of Energy. Museum development at Hanford may include the B Reactor, Bruggemann's Warehouse, Hanford High School, Pump House, and White Bluffs Bank.
Timeline of major events
| Year | Date | Event |
| 1943 | October | U.S. Army Corps of Engineers breaks ground to build B Reactor |
| 1944 | September 13 | First uranium fuel slug loaded into B Reactor |
| 1944 | September 26 | Initial reactor criticality achieved |
| 1945 | February 3 | B Reactor plutonium delivered to Los Alamos |
| 1945 | July 16 | B Reactor plutonium used in world's first nuclear explosion. |
| 1945 | August 9 | B Reactor plutonium used in Fat Man bomb dropped on Nagasaki, Japan |
| 1946 | March | B Reactor operations suspended |
| 1948 | June | B Reactor operation resumed |
| 1949 | March | B Reactor begins production of tritium for use in hydrogen bombs |
| 1954 | March 1 | First use of B Reactor tritium in a test detonation of a hydrogen bomb at Bikini Atoll |
| 1968 | January 29 | Atomic Energy Commission directs shutdown of B Reactor |
| 1976 | B Reactor declared National Historic Mechanical Engineering Landmark by American Society of Mechanical Engineers | |
| 2008 | B Reactor declared National Historic Landmark by U.S. Department of Interior and National Park Service | |
| 2009 | U.S. Department of Energy announces public tours | |
| 2011 | July | National Park Service recommends B Reactor be included in a national historic park commemorating the Manhattan Project. |
| 2014 | December | 2015 National Defense Authorization Act includes B reactor in Manhattan Project National Historical Park |
| 2015 | November 10 | Manhattan Project National Historical Park formally established by Memorandum of Agreement |