Armavia Flight 967


Armavia Flight 967 was a scheduled international passenger flight operated by Armavia from Zvartnots International Airport, Zvarnots in Armenia to Sochi, a Black Sea coastal resort city in Russia. On 3 May 2006, the aircraft operating the route, an Airbus A320-200, crashed into the sea while attempting to go-around following its first approach to Sochi airport, killing all 113 aboard.
The accident was the first major commercial airline crash in the year of 2006. It was Armavia's first and only fatal crash.

Flight

The aircraft took off from Zvartnots International Airport at a scheduled departure time at 01:45 Armenian Daylight Time and with a scheduled arrival time at Sochi International Airport of 02:00 Moscow Daylight Time.
In order to make their decision for departure, the crew obtained the observed weather data and the weather forecast for the takeoff, landing and alternate aerodromes all of which met the requirements for IFR flights. All the crew were correctly licensed and adequately rested to operate the flight.
The airplane took off from Zvartnots airport at 20:47. There were 113 occupants on board: 105 passengers, 2 pilots,1 aircraft engineer and 5 flight attendants. Takeoff, climb and cruise were uneventful.
The first communication between Sochi approach controller and the crew took place at 21:10. At that moment the airplane was beyond the coverage area of the Sochi radar. Up until 21:17 the approach controller and the crew discussed the observed and forecast weather, and as a result the crew decided to return to Yerevan. At 21:26, after the decision had already been made, the crew asked the controller about the latest observed weather. At 21:30 the controller informed the crew that visibility was and the cloud ceiling. At 21:31 the crew decided to continue the flight to Sochi airport.
The next communication with the approach controller was at 22:00. At that moment the aircraft was descending to an altitude of and was being tracked by the Sochi radar. The approach controller cleared the flight for a descent to and reported the observed weather at Sochi, as at 22:00, for runway 06, which was above the minimums.
The crew was then handed over to the holding and tower controllers, and was cleared for descent to, before entering the turn to the final approach. Whilst performing the turn, the runway extended centreline was overshot. After eliminating the deviation, the crew started descending the aircraft along the glide slope, following the approach pattern.
At 22:10 the crew reported that the gear was down and that they were ready for landing. In response they were advised that they were from the airport and that the weather was now visibility x cloud ceiling, and were cleared for landing. However, about 30 seconds later, the controller advised the crew of the observed cloud ceiling at and instructed them to cease their descent, abandon the landing attempt, and carry out a right turn and climb to and also to contact the holding controller, who gives instructions for entering the airport's holding pattern.
The last communication with the crew was at 22:12. After that the crew did not respond to any of the controller's calls. At 22:13 the aircraft struck the water, and broke up on impact.

Aircraft

The aircraft involved was built in France with its first flight in June 1995. It had a MSN number of 547 with a test registration code of F-WWIU. The aircraft was delivered in 1995 to Ansett Australia, registered in Australia as VH-HYO. It was acquired by Armavia in 2004 registered as EK-32009 with its name as Mesrop Mashtots. Armavia repainted the aircraft with its new livery on 31 October 2004. The aircraft had flown more than 10,000 hours before the crash.

Passengers and crew

Most of the passengers were citizens of Armenia. According to reports, the flight had 85 Armenian citizens, 26 Russian citizens, one Georgian citizen, and one Ukrainian citizen.
;Citizenship of the passengers and crew
The Captain of Flight 967 was 40-year-old Grigor Grigoryan. Born in 1966, he had completed his primary training in Krasnokutsk Civil Flight School. He graduated in 1986 and also graduated from Moscow Institute of Civil Aviation Engineers. He joined Balaklavsky United as a co-pilot in 1986. He then joined Ararat Airlines in 1997 as a Captain of a Yakovlev Yak-40. He then joined Armavia as a co-pilot of an Airbus A320 in 2004 and subsequently promoted to a Captain in 2005. He had passed a test for an Airbus A320 Captain in SAS Flight Academy in Stockholm, Sweden with satisfying results. Captain Grigoryan had a total of 5,458 hours of flight experience, including 1,436 hours on the Airbus A320.
The First Officer of Flight 967 was 29-year-old Arman Davtyan. He was born in 1977 and had completed his primary training in Ulyanovsk Civil Flying School and graduated in 1999. He then joined Chernomor-Avia in December 2001 as a co-pilot of a Tupolev Tu-154. He joined Armavia in 2002, joined Armenian Airlines in 2004, and then joined Armavia again in the same year. First Officer Davtyan had passed a training course for an Airbus A320 in SAS Flight Academy in Stockholm, Sweden with satisfying results. He had 2,185 flight hours, with 1,022 of them on the Airbus A320.

Recovery efforts

Flight 967 disappeared from Sochi's radar at 02:13 local time. Chief of Flight Operation N.G Savelyev alerted all the search and rescue services in the area and deployed an Mi-8 helicopter. At 02:19, the disappearance of Flight 967 was informed to Russia's Minister of Emergencies. A search helicopter was ready for take off to find the missing flight, but was not allowed by Sochi due to the deteriorating weather. The search and rescue operation was then suspended. At 04:08, the Ministry of Emergency's boat Valery Zamarayez found the probable crash area. Rescuers then went to the search area. From 07:30 to 12:30, the search and rescue team recovered 9 body parts from the crash site.
Search and rescue personnel only managed to recover some of the flight's debris. They recovered the Airbus' nose, landing gear, fin, elevator, and several other fragments. Wiring and electronic units were also found. A total of 52 body fragments were found by the search and rescue team as well. The BEA noted that, at the time when Flight 967 impacted the sea, the landing gear was extended. The lower part of the rudder was severely damaged due to the impact forces. Several parts of the aircraft elevator were also damaged. Some of the aircraft parts recovered from the sea were severely deformed.

Causes

Weather

The weather at the time was considered to be fine. Low pressure was present near Sochi at the time. A cold front was also detected and was forming in the Caucasian Edge and further to the east of Turkey at the time. Rain was also present in Adler. In the spring transition period, low clouds often occurred in the Caucasian Edge, which, could have limited visibility for the pilots. This proved to be dangerous, as most Controlled Flight Into Terrain occurs due to this kind of cloud.
Prior to take off from Yerevan, the crew was briefed on the weather conditions in Sochi. At the time, the weather in Sochi was fine. After the take off of Flight 967, the pilots were given another weather briefing. It was still in good condition, with considerable clouds, mist, and light rain. The weather at the time would not have allowed for a vortex. In the following hours, the probability that a vortex might occur was reduced to zero. By the time Flight 967 entered Sochi, the weather conditions had deteriorated. A cold front wave occurred in Sochi, producing Cumulonimbus cloud. The rain intensified, and the visibility was reduced to 1,500 m. For several minutes, the weather became better for landing. The controllers instructed Flight 967 to abort their descent and conduct a go-around immediately, as low clouds were present in Sochi Airport. Shortly afterwards, Flight 967 disappeared from Sochi Radar.

Recorders analysis

Shortly after Flight 967 impacted water, the radio beacon signals, known as the Emergency Locator Transmitter, started to sound. French BEA retrieved the submerged Cockpit Voice Recorder and Flight Data Recorder from the Black Sea and found that there were only minor damages in both recorders. BEA later examined both the CVR and the FDR.

Examination

Based on the examination, the flight was uneventful until the approach. However, during the cruise stage of the flight, First Officer Davtyan stated: "**** it.. who operates such flights with the jitter and not enough sleep". This may indicate that he didn't have adequate sleeping hours, meaning he was fatigued at the time. The BEA also noted that neither pilot understood how the autopilot of an Airbus A320 works. Analysis of the internal communications at this stage of the flight shows that Captain Grigoryan was annoyed by the fact that in DESCENT mode the descent rate was not as high as he expected. BEA noted that in this mode, the descent rate is calculated automatically, depending on a number of parameters describing the descent, e.g. the aircraft attitude in relation to the preset profile and so on. This fact shows that either the Captain did not fully understand the autopilot work algorithm in the DESCENT mode, or was in a state of high psycho-emotional strain with an imperative to land at Sochi as soon as possible.
Flight 967 was then instructed by Sochi Tower to pass waypoint GUKIN and TABAN. It then passed both waypoints. While banking to turn to final approach, the rain started. First Officer Davtyan then overreacted by saying exclamation words, possibly due to emotional stress. The Sochi controller then told the crew of Flight 967 that the weather in Sochi had deteriorated, and instructed the pilot to abort their descent. The crew overreacted to this report, responding with negative words and expletives to the controller. The crew had been discussing the issue for three minutes, swearing about the controller's actions even between the items on the check list. Such behaviour by the crew must have inevitably resulted in an increase of their psycho-emotional stress.
The aircraft climbed, started to bank and the flaps were extended to 18°. At this point, Captain Grigoryan was heard in the CVR saying: "**** him" to the Sochi controller. The crew then contacted Sochi's holding controller, as well as the final controller. They then selected the "glide-slope capture" descent mode, which is an automatic descent. The aircraft was descending with two engaged autopilots and engaged auto-thrust. The speed was controlled by the auto-thrust at the target speed of, stabilised on the glide-slope, in the landing configuration and ready for landing. The crew then proceed to the landing check list.
Sochi Tower instructed them to abort their descent and conduct a go-around, as low clouds had formed near the airport. The aircraft climbed, the thrust levers were moved to climb position, the flaps and slats remained fully extended, and the landing gear remained fully extended. A few minutes later, the "Speed Speed Speed" warning sounded. This warning advises the crew that "the aircraft energy is decreasing to the limit, below which the engine thrust must be increased to regain a positive angle of the flight path". At the moment when the aural warning sounded, the aircraft altitude was, the crew then pushed the TO/GA button.
BEA stated that none of the crew's actions were important and necessary for a go-around procedure, such as extending the flaps and the landing gear. This demonstrated that, at that time, both flight crews' condition were not at the optimum level. BEA also suspected that the LOW ENERGY warning wasn't detected or noticed by the crew.
The autopilot was then disengaged by the crew, as they cast doubts on the autopilot Captain Grigoryan then banked the aircraft to the right.
Both crew members then became more physically and emotionally stressed, as further conversations among them revealed that their intonations became higher and higher. The aircraft then decreased its pitch up attitude and banked to the right. Then, one of the crew stepped on the rudder pedals, causing the rudder to deflect. This was not necessary. The BEA suspect that Captain Grigoryan stepped the pedals, while under psycho-emotional stress. Due to the emotional stress he was suffering at the time, he didn't notice that he had stepped the pedals.
BEA then found that the crew may have been suffering a somatogravic illusion in flight. Somatogravic illusion, in aviation, is a type of optical illusion which can cause the crew to think that they are pitching up, while in reality, they are not. This could happen during night-time flying accompanied by the lack of monitoring of the flight's indicator. Somatogravic illusion was responsible for the crash of Gulf Air Flight 072 in Bahrain. However, the BEA also suspected the specific features of the speed indication on the PFD, especially speed limitations for the Airbus A320 configuration that are shown as the red bars at the top of the speed indication strip. One of the crew members might have adopted the reflex acquired in training, for example, in response to a TCAS warning when the pilot is anxious to avoid the displayed red part of the instrument scale, which may result in the instinctive forward movement of the side stick, especially when the pilot is in a state of psycho-emotional strain. This version is substantiated by the fact that the pilot was monitoring the flight speed and its limitations that depended on the Airbus A320 configuration and retracted the flaps and slats in a timely manner, and the control inputs on the side stick coincided with the moments when the current speed was getting close to the limit value. However, neither of these probable causes have enough evidence.
The crew of Flight 967 then communicated with Sochi Tower. Their words were not completed; "Sochi Radar, Armavia 967...". This was the last communication from Flight 967, as Captain Grigoryan ordered First Officer Davtyan to fully extend the flaps.
After First Officer Davtyan extended the flaps to full, few seconds later, the master warning sounded, and continued to do so until the end of the recording. The speed at the time was too fast, which could tear the flaps apart and could cause the plane to crash, similar to Austral Lineas Aereas Flight 2553. The plane was banking to the right. Flight 967 began a nose-down attitude and the flaps then retracted to 18°. Captain Grigoryan then made an 11° nose-down input, causing the plane to descend even further.
Captain Grigoryan aggravated the condition further by making a right bank input, causing the plane to bank severely to the right, with a roll angle of 39°. The Ground Proximity Warning System then sounded. First Officer Davtyan then ordered Captain Grigoryan to level off. At this moment, First Officer Davtyan intervened and moved the stick to the left position to counter the increasing right bank, while Captain Grigoryan continued making his control inputs to increase the right bank. Apparently, First Officer Davtyan was trying to counter the bank only, as he also made a nose-down input, causing the plane to descend even further.
While intervening, First Officer Davtyan had not pressed the take-over push button, therefore, both pilot's control inputs were added and prohibited. This is known as dual input. Such dual piloting is prohibited. The dual input warning should have sounded at the time, however, because its priority is lower than the Ground Proximity Warning, it did not, and so neither pilot knew that they were making dual inputs on the aircraft.
The crew's attention might have been distracted by the controller's direction. The controller was sending the crew a 20-second long message, which was too long. While the plane was descending, one of the crew members suddenly moved the thrust lever way back, into its idle position, and then moved the thrust lever forward, causing the autothrottle to disengage. The crew then desperately tried to lift the plane up, but the plane impacted water at a speed of, killing all on board instantly.

Primary conclusions of the final accident report

The crash of Armavia Flight 967 was a controlled flight into terrain, specifically water, while conducting a climbing maneuver after an aborted approach to Sochi airport at night with weather conditions below landing minimums for runway 06.
While performing the climb with the autopilot disengaged, the captain, being in a psychoemotional stress condition, made nose down control inputs due to the loss of pitch and roll awareness. This started the abnormal situation. The captain's insufficient pitch control inputs led to a failure to recover the aircraft and caused it to crash.
Along with the inadequate control inputs from the captain, the contributing factors of the crash were also the lack of monitoring the aircraft's pitch attitude, altitude and vertical speed by the first officer and no proper reaction by the crew to GPWS warnings.

Contributory factors and shortcomings

Source:
TimeFactor or ShortcomingApplicable Policy
During descent and approach the crew constantly held conversations having nothing to do with the operation of the aircraft.
The A320 Flight Crew Techniques Manual, which was approved by the Civil Aviation Administration of the Republic of Armenia and according to which the captain passed his training before starting flights with the airline, does not contain the requirement for passing the Upgrade to Captain programme. The captain did not pass this training. This training programme was made mandatory in the next revision of the FCTM.A320 Flight Crew Techniques Manual
The Flight Operations Department of Armavia does not comply with the requirement that airlines analyse flight operations with the use of the flight data recorder and cockpit voice recorder recordings for aircraft with the certified maximum takeoff weight exceeding. As such it was impossible to completely evaluate the professional skill levels of the flight crew members.ROLRGA RA Section 11.2 and ICAO Annex 6 Part 1 Chapter 3
Armavia does not keep records on the approaches and landings in complicated weather conditions performed by their captains.ROLRGA RA-2000 Sections 4.5.33 and 6.1.5
21:16Sochi approach control advised the crew of the trend weather forecast for landing as visibility x cloud ceiling and did not identify the trend as “AT TIMES”. This inaccuracy while reporting the weather to the crew was not directly connected with the cause of the aircraft accident, but it influenced the initial decision of the crew to return to Zvartnots.
22:01The approach controller advised the crew of the observed weather at Sochi and by mistake said the cloud ceiling was "considerable" at, instead of, however this did not influence the captain's decision.
22:03The crew did not report the selected system and mode of instrument approach.Holding Controller's Operation Manual, Section 4, item 4.2.1
22:11The final controller at Sochi was informed by the weather observer of the current observed weather: A cloud ceiling of, below the established minimums. Based on this information, the final controller instructed the crew: "Abort descent, clouds at, right-hand turn, climb to ", instructions not compliant with regulations. However, the controller had a right to order the go-around.Civil Flight Operations Guidance 85 Section 6.5.16 and the Final Controller's Operation Manual, items 4.3 and 4.3.1
The controller had a right to order the go-around.The AIP of Russia
The weather forecast for Sochi for the period from 18:00 to 03:00 was not verified with regard to visibility in the "At times" group.
22:11The weather observer did not complete the special weather report when the cloud ceiling descended to, though to do so was required.Guidance for Meteorological Support in Civil Aviation 95, Sections 4.3.1 and 4.4.1 d; Instruction for meteorological support at Sochi; Criteria for Issuance of a Special Weather Report, Annex 8
The recommendation for ATIS broadcast was not entirely fulfilled.Federal Air Transport Administration and Hydrometeorology and Environment Monitoring Service Joint Order No. 62/41 "On approval and implementation of Instruction for ATIS broadcast content in English and Russian" of 20 March 2000
In the course of reading out FDR data, a number of discrepancies were found in the documentation describing the logic of binary signal recordings.
While performing manoeuvres in the landing configuration with the autopilot and autothrust engaged, the LOW ENERGY WARNING may sound, which Airbus considers as an abnormal situation.

Safety recommendations

To eliminate the shortcomings revealed during investigation of this accident, the final accident report made 22 safety recommendations as follows:
Number of
Recommendations		Target
5Aviation administrations of the CIS countries
1Aviation administrations of the CIS countries jointly with industrial and scientific and research organizations
6Civil Aviation Administration of the Republic of Armenia and Armavia airline administration
2Federal Air Navigation Service of the Russian Federation
2Federal Service for Hydrometeorology and Environmental Monitoring
2Federal State Unitary Enterprise “State Corporation for Air Traffic Management"
4Airbus Industrie